This is a working overview of freeze-drying, written for readers who want more than a one-paragraph summary but less than a textbook.
Reviewed 2025-12-17. Anything still debated is marked as such rather than presented as settled.
Lyophilization, also called freeze-drying, removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts free water into ice and may also produce a glassy phase. Primary drying then lowers chamber pressure so ice sublimes directly to vapor without passing through a liquid stage. Secondary drying raises the temperature modestly to remove bound water. The result is a porous, dry solid that usually reconstitutes quickly. Each stage influences pore structure, residual moisture, and stability.
The physics of lyophilization depends on phase boundaries and heat and mass transfer. During primary drying, heat supplied to the product must equal the latent heat of sublimation, while water vapor moves through the drying cake to the condenser. If shelf temperature or pressure is set too high, the ice front can exceed the collapse temperature, causing meltback or pore collapse. If conditions are too cold, drying slows and costs rise. Formulation excipients, vial geometry, and freezing rate alter these limits.
Equipment for lyophilization includes a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. A refrigeration system cools the shelves and condenser below the product's freezing point. Process monitoring often uses Pirani and capacitance manometers, thermocouples, and resistance sensors. Cycle development balances product quality with time and energy use. Some products are annealed during freezing to improve crystallization of bulking agents. Open questions remain about scaling cycles between laboratory, pilot, and production freeze-dryers.
The low pressure used during drying allows water vapor to move from the ice surface to a cold condenser. Energy supplied as heat drives sublimation but must stay below the collapse temperature of the frozen matrix. If the product becomes too warm, the frozen structure may soften or melt, reducing pore formation and slowing drying. Formulations often include bulking agents, stabilizers, or buffers to support a rigid cake. The final moisture content depends on formulation, freezing rate, and the length of secondary drying.
Freeze-drying is distinct from simple evaporation and from spray drying. Evaporation removes water at temperatures above freezing, while spray drying rapidly dries droplets in a heated gas stream. Lyophilization avoids high temperatures, which can be useful for heat-sensitive materials such as proteins, vaccines, and some foods. The porous cake produced by sublimation dissolves or rehydrates more quickly than a dense dried mass. Not all materials tolerate freezing or the pH shifts that can occur as solutes concentrate during ice formation.
Lyophilization removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts liquid water into ice and fixes the structure of the sample. After freezing, primary drying lowers pressure so ice changes directly to vapor without passing through a liquid phase. Secondary drying then removes bound water that remains after ice sublimation. The result is a dry, porous solid that often retains its original shape.
| Property | Value | Notes |
|---|---|---|
| Common synonyms | Freeze-drying; lyophilisation; cryodesiccation | Regional spelling and historical terms. |
| Primary drying pressure | 0.05-0.5 mbar (5-50 Pa) | Kept below the triple point of water; product-specific. |
| Shelf temperature range | -40 to +40 °C | Freezing, primary, and secondary stages use different set points. |
| Cycle duration | 12-72 hours | Depends on fill volume, formulation, and equipment. |
| Condenser temperature | -50 to -80 °C | Must remain below the product's ice temperature. |
The physical chemistry of freezing influences whether a formulation forms an amorphous glass or a crystalline solid. Amorphous systems can collapse if product temperature rises above the glass transition temperature of the freeze concentrate. Crystalline systems may show eutectic melting, where ice and solute melt together at a fixed temperature. Formulators add bulking agents, lyoprotectants, and buffers to preserve structure and biological activity. The optimum cycle keeps product temperature below critical thresholds during primary drying while allowing efficient sublimation.
Lyophilization is a dehydration process that removes water from a frozen material by sublimation under low pressure. The material is first frozen so that water becomes ice; then the surrounding pressure is lowered below the vapor pressure of ice. Heat is applied gently so ice changes directly to vapor without passing through a bulk liquid phase. The vapor is collected on a cold condenser, leaving a dry porous matrix. This process differs from simple evaporation because the material remains frozen during the main drying stage.
The process usually has three stages: freezing, primary drying, and secondary drying. Freezing sets the ice crystal structure and can determine pore size in the final cake. Primary drying removes free ice by sublimation at low pressure and low shelf temperature. Secondary drying removes bound water by raising the shelf temperature, although some water may remain as part of the solid. Cycle parameters depend on formulation, fill volume, vial type, and equipment performance.
The physics of lyophilization couples heat transfer, mass transfer, and phase behavior. Sublimation requires a vapor pressure difference between the ice front and the chamber, and the dried layer adds resistance to vapor flow. Amorphous formulations are characterized by a glass transition temperature of the maximally freeze-concentrated solute, often denoted Tg'. Crystalline bulking agents can provide structure, while amorphous excipients stabilize labile components. Open questions remain about spatial heterogeneity, edge effects, and how laboratory cycles scale to production.
Lyophilization is a drying process in which a solvent, usually water, is removed from a frozen material by sublimation under reduced pressure. The material is first solidified, then placed under vacuum so that ice transitions directly to vapor without a bulk liquid phase. This approach suits heat-sensitive substances that would degrade during conventional evaporation. Primary drying removes unbound ice, while secondary drying reduces water that remains adsorbed to the solid matrix. The result is a porous, lightweight solid that can be reconstituted later.
Miriam Gross, Lady Owen; literary editor and writer; literary editor of The Observer, arts editor of The Daily Telegraph, literary editor of The Sunday Telegraph, senior editor (and co-founder) of Standpoint; edited Channel Four's Book Choice; at The Observer, she conducted a series of interviews, with, among others, the poet Philip Larkin, playwright Harold Pinter, thriller writer John le Carré, painters Francis Bacon and David Hockney, Nobel Prize-winning Russian poet Joseph Brodsky, novelist Anthony Powell, philosopher and historian Sir Isaiah Berlin, philosopher A.J. Ayer, and Stalin's daughter Svetlana Stalin; has written for the Financial Times; has also served as judge on the Booker prize and on George Orwell memorial prize. Susanna Gross, literary editor of The Mail on Sunday since 1999 and columnist for The Spectator; previously worked as an editor at the Daily Mail, was features editor of Harper's Bazaar, and was deputy editor of The Week; daughter of literary critic and writer John Gross and literary editor Miriam Gross, and the granddaughter of humanitarian Kurt May, she is married to novelist and critic John Preston; brother Tom Gross is a journalist and international affairs commentator, specialising in the Middle East; stepdaughter of Sir Geoffrey Owen.
Anticoagulated blood is collected from normal, healthy individuals. Acid citrate dextrose is preferred. Peripheral blood mononuclear cells (PBMC) are harvested from the blood sample using a Ficoll-Paque® density gradient. The PBMC's are washed using a phosphate-buffered saline (PBS) and then suspended in tissue culture media in order to keep the monocytes viable. The PBMC-media mixture is then added to a tissue culture chamber slide. Monocytes will adhere to the glass slide forming a monocyte monolayer. Serum is mixed and incubated at body temperature (37°C) with a 5% group O RBC suspension. (This step sensitizes or coats RBC with antibody) The sensitized RBC's are washed with PBS to remove any unbound antibody or interfering substances. The washed, sensitized RBC are then added to the monocyte monolayer tissue culture chamber slide. After a 60-minute, 37°C incubation, the supernatant is removed from the chamber slides and rinsed with PBS. Once the slide is completely dry, it is stained with a Wrights-Giemsa stain. At least 600 (200 if positivity is greater than 20%) monocytes are observed under the microscope for evidence of RBC phagocytosis. A positive and negative control is also performed in tandem with the patient specimen for quality assurance.
Thiol additives : The initial transthioesterification step of the native chemical ligation reaction is catalyzed by thiol additives. The most effective and commonly used thiol catalyst is 4-mercaptophenylacetic acid (MPAA), (ref).
From the earliest finds, opium has appeared to have ritual significance, and anthropologists have speculated ancient priests may have used the drug as a proof of healing power. In Egypt, the use of opium was generally restricted to priests, magicians, and warriors. Its invention is credited to Thoth, and it was said to have been given by Isis to Ra as treatment for a headache. A figurine of a goddess dated to around 1300 BC from the Minoan period contains three hairpins shaped as poppy capsules, all of which contain slits that suggest the Cretans knew the method of extracting opium. Additionally, her smile and parting lips suggests that she may be in a state induced by the opium. This has influenced some scholars to call her the "goddess of ecstasy". Further evidence confirms the use of opium in the Mediterranean since the Late Bronze Age due to a number of small lekythi from various places in Crete. These lekythi are supposed to have contained pharmaceutical opium due to the shape of the jars being analogous to those of the poppy head. Additionally, each jar is decorated with vertical stripes that are very similar to the process of cutting into the poppy to extract the sap. There is further evidence for the use of opium during this era due to painted pyxis. These would be decorated with painted poppy capsules and birds holding both poppy capsules and poppy stalks. Opium's use in the ancient Mediterranean world is well written about, with many authors discussing its uses.
Sources: en.wikipedia.org
Ultrasound is routinely used in the evaluation of cirrhosis. It may show a small and shrunken liver in advanced disease. On ultrasound, there is increased echogenicity with irregular appearing areas. Other suggestive findings are an enlarged caudate lobe, liver surface nodularity widening of the fissures and enlargement of the spleen. An enlarged spleen, which normally measures less than 11–12 cm (4.3–4.7 in) in adults, may suggest underlying portal hypertension. Ultrasound may also screen for hepatocellular carcinoma and portal hypertension. This is done by assessing flow in the hepatic vein. An increased portal vein pulsatility may be seen. However, this may be a sign of elevated right atrial pressure. Portal vein pulsatility is usually measured by a pulsatility index (PI). A number above a certain value indicates cirrhosis (see table below).
Inhibition of fertilization by administration of progesterone during the luteal phase was also demonstrated in animals between 1947 and 1949. Ovulation inhibition by progesterone in animals was subsequently re-confirmed and expanded on by Gregory Pincus and colleagues in 1953 and 1954. Findings on inhibition of ovulation by progesterone in women were first presented at the Fifth International Conference on Planned Parenthood in Tokyo, Japan in October 1955. Three different research groups presented their findings on this topic at the conference. They included Pincus (in conjunction with John Rock, who did not attend the conference); a nine-member Japanese group led by Masaomi Ishikawa; and the two-member team of Abraham Stone and Herbert Kupperman. The conference marked the beginning of a new era in the history of birth control. The results were subsequently published in scientific journals in 1956 in the case of Pincus and in 1957 in the case of Ishikawa and colleagues. Rock and Pincus also subsequently described findings from 1952 that "pseudopregnancy" therapy with a combination of high doses of diethylstilbestrol and oral progesterone prevented ovulation and pregnancy in women. Unfortunately, the use of oral progesterone as a hormonal contraceptive was plagued by problems. These included the large and by extension expensive doses required, incomplete inhibition of ovulation even at high doses, and a frequent incidence of breakthrough bleeding.
They were involved in the Kosovo War helping KLA guerillas behind Serbian lines. According to Albanian sources one SAS sergeant was killed by Serbian special forces. The Gulf War, in which A, B and D squadrons deployed, was the largest SAS mobilisation since the Second World War, also notable for the failure of the Bravo Two Zero mission. In Sierra Leone it took part in Operation Barras, a hostage rescue operation, to extract members of the Royal Irish Regiment. Following the September 11 attacks on the United States by al-Qaeda in 2001, two squadrons of 22 SAS, later reinforced by members of both the Territorial SAS units, deployed to Afghanistan as part of the Coalition invasion at the start of the War in Afghanistan, to dismantle and destroy al-Qaeda and to deny it a safe base of operations in Afghanistan by removing the Taliban from power in the war on terror. The Regiment carried out Operation Trent, the largest operation in its history, which included its first wartime HALO parachute jump. Following the invasion, the Regiment continued to operate in Afghanistan against the Taliban and other insurgents until 2006, when its deployment to Iraq became its focus of operations, until 2009 when the SAS redeployed to Afghanistan. The regiment took part in the Iraq War, notably carrying out operations in Iraq before the 2003 invasion.
The use of acupuncture in Germany increased by 20% in 2007, after the German acupuncture trials supported its efficacy for certain uses. In 2011, there were more than one million users, and insurance companies have estimated that two-thirds of German users are women. As a result of the trials, German public health insurers began to cover acupuncture for chronic low back pain and osteoarthritis of the knee, but not tension headache or migraine. This decision was based in part on socio-political reasons. Some insurers in Germany chose to stop reimbursement of acupuncture because of the trials. For other conditions, insurers in Germany were not convinced that acupuncture had adequate benefits over usual care or sham treatments. Highlighting the results of the placebo group, researchers refused to accept a placebo therapy as efficient. According to Singh and Ernst "the WHO acupuncture panel did not include a single critic of acupuncture. It was quite simply a group of believers who unsurprisingly were less than objective in their assessment."
=== University of Queensland === Commencing in March 1916 at the University of Queensland he studied science, specialising in biology under Thomas Harvey Johnston, where he received training in animal morphology. He was awarded his Bachelor of Science in 1919. During his honours course, he produced his first research paper in 1918: an anatomical study of the echiuroid worm (pseudobonelia). He received his Master of Science in 1921, at the age of 25. He wanted to study medicine, but there was no medical school in Queensland, so instead continued into zoology. In 1920 he was the beneficiary of a Walter and Eliza Hall Fellowship in economic biology. He worked with scientists researching the control of the blowfly and prickly pear in Queensland, and was involved in the campaign to eradicate hookworm. Tiegs was the first graduate of the University of Queensland to be awarded the degree of doctor of science.
Sources: en.wikipedia.org
== Outlook == The long-term course of MCTD may vary. Long-term follow-up studies have shown that MCTD can progress to a moderate disease with a favorable prognosis, or patients can acquire a significant condition with vascular alterations driven by pulmonary hypertension and increased mortality. Approximately one-third of people with MCTD have a benign course and go into remission, while the other one-third have a more aggressive course with a poor response to treatment. Approximately one-third of MCTD patients improved with immunosuppressive medication but continued to require immunosuppressive therapy after several years. The prevalence of pulmonary hypertension was related to the worst prognosis and a high mortality rate, making it the most significant complication in MCTD.
=== Immigration === Pritzker supports Syrian refugees, and criticized the first Trump administration and Rauner for "turning a blind eye on them". He also supports enhancing funding for immigrant and refugee services, increasing health care options for undocumented immigrants, improving the U-Visa certification process for victims of violent crimes, and providing access to financial aid for undocumented students such as DACA recipients. He has said he would sign the "Illinois Trust Act", a pro-immigration bill. In January 2025, when asked about the mass deportation of illegal immigrants in the second presidency of Donald Trump, Pritzker spoke in favor of deporting convicted criminals who are undocumented, but criticized the targeting of "law-abiding residents" who are integrated into communities.
The point is sometimes made that, in fact, the adoption by the Liberal Governments of 1905-14 of several major social welfare measures, including old-age pensions and health and unemployment insurance, provoked remarkably little resistance within the party. The measures that did occasion some overt resistance in the party were the Budgets for 1909 and 1914, which provided for the taxes to help finance new measures of reform as well as large increases in naval expenditure. It was, in other words, over the questions of the cost and financing of social reform that the main debate over social reform was waged within the Liberal Party.
In biochemistry, a transferase is any one of a class of enzymes that catalyse the transfer of specific functional groups (e.g. a methyl or glycosyl group) from one molecule (called the donor) to another (called the acceptor). They are involved in hundreds of different biochemical pathways throughout biology, and are integral to some of life's most important processes. Transferases are involved in myriad reactions in the cell. Three examples of these reactions are the activity of coenzyme A (CoA) transferase, which transfers thiol esters, the action of N-acetyltransferase, which is part of the pathway that metabolizes tryptophan, and the regulation of pyruvate dehydrogenase (PDH), which converts pyruvate to acetyl CoA. Transferases are also utilized during translation. In this case, an amino acid chain is the functional group transferred by a peptidyl transferase. The transfer involves the removal of the growing amino acid chain from the tRNA molecule in the A-site of the ribosome and its subsequent addition to the amino acid attached to the tRNA in the P-site. Mechanistically, an enzyme that catalyzed the following reaction would be a transferase:
The Twin Towers, Marriott World Trade Center (3 WTC), 7 WTC, and St. Nicholas Greek Orthodox Church were destroyed. The U.S. Customs House (6 World Trade Center), 4 World Trade Center, 5 World Trade Center, and both pedestrian bridges connecting buildings were severely damaged. All surrounding streets were in ruins. The last fires at the World Trade Center site were extinguished on December 20. The Deutsche Bank Building was damaged and was later condemned as uninhabitable because of toxic conditions; it was deconstructed starting in 2007. Buildings of the World Financial Center were damaged. The Borough of Manhattan Community College's Fiterman Hall was condemned due to extensive damage, and then reopened in 2012. Other neighboring buildings (including 90 West Street and the Verizon Building) suffered major damage but have been restored. World Financial Center buildings, One Liberty Plaza, the Millennium Hilton, and 90 Church Street had moderate damage and have been restored. Communications equipment on top of the North Tower was also destroyed, with only WCBS-TV maintaining a backup transmitter on the Empire State Building, but media stations were quickly able to reroute the signals and resume their broadcasts. The PATH train system's World Trade Center station was located under the complex and was demolished when the towers collapsed. The tunnels leading to Exchange Place station in Jersey City were flooded with water. The station was rebuilt as the $4 billion World Trade Center Transportation Hub, which reopened in March 2015.
Sources: en.wikipedia.org
Simple drying usually removes water by evaporation from a liquid or solid, often with heat. Lyophilization first freezes the material and then removes ice by sublimation under vacuum. This avoids prolonged exposure to liquid water and high temperatures.
Reduced pressure lowers the boiling point of water and allows ice to sublime at temperatures below freezing. It also helps remove water vapor from the product toward the condenser. The exact pressure is chosen to stay below the triple point of water.
No. Materials with low solids content or high volatile solvents may form weak or collapsed cakes. Some proteins and cells require stabilizers to survive freezing and drying stresses. Feasibility depends on formulation and process design.
Lyophilization relies on sublimation, so water moves from solid ice to vapor without becoming liquid. The material is frozen, pressure is reduced, and controlled heat is supplied. Vapor is captured on a cold condenser, leaving a dry porous solid.