sublimation is one of those subjects where the details matter more than the headlines. This page pulls together the background, the mechanisms, and the practical points readers ask about most.
Updated 2025-07-28. Numbers and descriptions here follow the published literature rather than marketing material.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
Lyophilization is a dehydration technique in which a product is frozen and the solvent is removed under reduced pressure. The low pressure allows ice to sublimate directly into vapor without passing through a bulk liquid phase. This differs from conventional drying, where heat drives evaporation and can damage heat-sensitive structures. The process is used for biological materials, pharmaceutical formulations, and some foods. Its main advantage is preservation of porous structure and rapid reconstitution.
Freezing is the first stage and sets the ice structure that later becomes the pore network. The formulation is cooled below its freezing point, often with a controlled ramp, and solutes concentrate as ice forms. Primary drying then lowers chamber pressure and supplies heat to sublime the ice. The product temperature must stay below its collapse or eutectic temperature to prevent structural loss. Secondary drying raises the temperature modestly to remove bound water and achieve a low residual moisture.
A typical cycle begins with freezing, sometimes including an annealing step to control ice crystal size. Freezing conditions influence the pore network that later allows vapor escape. During primary drying, shelf temperature and chamber pressure are set so heat enters the product while its temperature stays below the collapse or eutectic point. Secondary drying then raises the shelf temperature to desorb bound water and lower residual moisture. Cycle design depends on formulation, fill volume, container type, and equipment capability.
The physics of lyophilization couples heat transfer, mass transfer, and phase behavior. Sublimation requires a vapor pressure difference between the ice front and the chamber, and the dried layer adds resistance to vapor flow. Amorphous formulations are characterized by a glass transition temperature of the maximally freeze-concentrated solute, often denoted Tg'. Crystalline bulking agents can provide structure, while amorphous excipients stabilize labile components. Open questions remain about spatial heterogeneity, edge effects, and how laboratory cycles scale to production.
| Property | Value | Notes |
|---|---|---|
| Common synonyms | freeze-drying, lyophilisation, cryodesiccation | Lyophilization is common in pharmaceutical literature. |
| Typical chamber pressure during primary drying | 0.05–0.5 mbar (5–50 Pa) | Must remain below the triple point of water. |
| Typical shelf temperature during freezing | −40 to −20 °C | Lower temperatures may be used for eutectic systems. |
| Typical residual moisture after secondary drying | 0.5–3% w/w | Product-dependent; low moisture improves stability but can cause over-drying. |
| Typical analytical method for residual moisture | Karl Fischer titration or loss on drying | Thermogravimetric methods are also used. |
Equipment for lyophilization includes a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. A refrigeration system cools the shelves and condenser below the product's freezing point. Process monitoring often uses Pirani and capacitance manometers, thermocouples, and resistance sensors. Cycle development balances product quality with time and energy use. Some products are annealed during freezing to improve crystallization of bulking agents. Open questions remain about scaling cycles between laboratory, pilot, and production freeze-dryers.
Lyophilization, also called freeze-drying, removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts free water into ice and may also produce a glassy phase. Primary drying then lowers chamber pressure so ice sublimes directly to vapor without passing through a liquid stage. Secondary drying raises the temperature modestly to remove bound water. The result is a porous, dry solid that usually reconstitutes quickly. Each stage influences pore structure, residual moisture, and stability.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
Lyophilization removes water by freezing a material and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intermediate liquid state. Because the material remains frozen during primary drying, the structure often stays porous. This porous matrix can rehydrate quickly when water is added back. The low pressure also allows vapor to leave the solid matrix without boiling.
== Derivatives == A derivative of Cecropin B is an anticancer polypeptide(L). Structure consists of mainly alpha helixes, determined by solution NMR. Protein molecular weight = 4203.4g/mol. Some of the cecropins (e.g. cecropin A, and cecropin B) have anticancer properties and are called anticancer peptides (ACPs). Hybrid ACPs based on Cecropin A have been studied for anticancer properties.
== Alternative carbon fixation pathways == RuBisCO is important biologically because it catalyzes the primary chemical reaction by which inorganic carbon enters the biosphere. While many autotrophic bacteria and archaea fix carbon via the reductive acetyl CoA pathway, the 3-hydroxypropionate cycle, or the reverse Krebs cycle, these pathways are relatively small contributors to global carbon fixation compared to that catalyzed by RuBisCO. Phosphoenolpyruvate carboxylase, unlike RuBisCO, only temporarily fixes carbon. Reflecting its importance, RuBisCO is the most abundant protein in leaves, accounting for 50% of soluble leaf protein in C3 plants (20–30% of total leaf nitrogen) and 30% of soluble leaf protein in C4 plants (5–9% of total leaf nitrogen). Given its important role in the biosphere, the genetic engineering of RuBisCO in crops is of continuing interest (see below).
Sanger then turned to sequencing DNA, which would require an entirely different approach. He looked at different ways of using DNA polymerase I from E. coli to copy single-stranded DNA. In 1975, together with Alan Coulson, he published a sequencing procedure using DNA polymerase with radiolabelled nucleotides that he called the "Plus and Minus" technique. This involved two closely related methods that generated short oligonucleotides with defined 3' termini. These could be fractionated by electrophoresis on a polyacrylamide gel and visualised using autoradiography. The procedure could sequence up to 80 nucleotides in one go and was a big improvement on what had gone before, but was still very laborious. Nevertheless, his group were able to sequence most of the 5,386 nucleotides of the single-stranded bacteriophage φX174. This was the first fully sequenced DNA-based genome. To their surprise they discovered that the coding regions of some of the genes overlapped with one another. In 1977 Sanger and colleagues introduced the "dideoxy" chain-termination method for sequencing DNA molecules, also known as the "Sanger method". This was a major breakthrough and allowed long stretches of DNA to be rapidly and accurately sequenced. It earned him his second Nobel prize in Chemistry in 1980, which he shared with Walter Gilbert and Paul Berg. The new method was used by Sanger and colleagues to sequence human mitochondrial DNA (16,569 base pairs) and bacteriophage λ (48,502 base pairs). The dideoxy method was eventually used to sequence the entire human genome.
The warfare grounded on certain uses of ICTs within an offensive or defensive military strategy endorsed by a state and aiming at the immediate disruption or control of the enemy's resources, and which is waged within the informational environment, with agents and targets ranging both on the physical and non-physical domains and whose level of violence may vary upon circumstances. Robinson et al. proposed in 2015 that the intent of the attacker dictates whether an attack is warfare or not, defining cyber warfare as "the use of cyber attacks with a warfare-like intent." In 2010, the former US National Coordinator for Security, Infrastructure Protection and Counter-terrorism, Richard A. Clarke, defined cyberwarfare as "actions by a nation-state to penetrate another nation's computers or networks for the purposes of causing damage or disruption". The target's own cyber-physical infrastructure may be used by the adversary in case of a cyber conflict, thus weaponizing it.
Sources: en.wikipedia.org
Psilocybin and psilocin are listed as Schedule I drugs under the United Nations 1971 Convention on Psychotropic Substances. However, mushrooms containing psilocybin and psilocin are not unlawful in some parts of the world. For example, in Brazil they are legal, but extractions from the mushroom containing psilocybin and psilocin remain unlawful. In the United States, growing or possessing Psilocybe cubensis mushrooms is unlawful in all states, but it is legal to possess and buy the spores for microscopy purposes. However, Denver, Colorado, decriminalized them for those 21 and up on May 8, 2019. Oakland, California, followed suit, decriminalizing psilocybin-containing mushrooms as well as the peyote cactus on June 4, 2019. Santa Cruz, California, decriminalized naturally occurring psychedelics, including psilocybin mushrooms, on January 29, 2020. On November 3, 2020, the state of Oregon decriminalized possession of psilocybin mushrooms for recreational use and granted licensed practitioners permission to administer psilocybin mushrooms to individuals age 21 years and older. In 1978, the Florida Supreme Court ruled in Fiske vs Florida that possession of psilocybin mushrooms is not unlawful, in that the mushrooms cannot be considered a "container" for psilocybin based on how the law is written, i.e., it does not specifically state that psilocybin mushrooms themselves are unlawful, but that the hallucinogenic constituents in them are.
Research on PFOA has demonstrated ubiquity, animal-based toxicity, and some associations with human health parameters and potential health effects. Additionally, advances in analytical chemistry in recent years have allowed the routine detection of low- and sub-parts per billion levels of PFOA in a variety of substances. In 2013, Gore-Tex eliminated the use of PFOAs in the manufacture of its weatherproof functional fabrics. Major companies producing PFOA signed with the Global PFOA Stewardship Program with the goal of elimination of PFOA by 2015. Since then it has been eliminated from the production of non-stick materials used in cookware. GenX has been introduced as a replacement for PFOA, but in a 2015 study which tested the effects on rats, GenX caused many of the same health problems as PFOA, but required much higher concentrations. This is because GenX (C3) is a short chain alternative to PFOA. GenX also has a significantly shorter half-life than PFOA so it is not as bio-persistent as PFOA or other long chain perfluorinated chemicals.
== Clinical significance == AST is similar to alanine transaminase (ALT) in that both enzymes are associated with liver parenchymal cells. The difference is that ALT is found predominantly in the liver, with clinically negligible quantities found in the kidneys, heart, and skeletal muscle, while AST is found in the liver, heart (cardiac muscle), skeletal muscle, kidneys, brain, and red blood cells. As a result, ALT is a more specific indicator of liver inflammation than AST, as AST may be elevated also in diseases affecting other organs, such as myocardial infarction, acute pancreatitis, acute hemolytic anemia, severe burns, acute renal disease, musculoskeletal diseases, and trauma. The elevated AST level in hemorrhagic fever caused by crimean-congo hemorrhagic fever virus is associated with high mortality rate. AST was defined as a biochemical marker for the diagnosis of acute myocardial infarction in 1954. However, the use of AST for such a diagnosis is now redundant and has been superseded by the cardiac troponins. Laboratory tests should always be interpreted using the reference range from the laboratory that performed the test. Example reference ranges are shown below:
Sagan again argued that some of the effects of the smoke could be similar to the effects of a nuclear winter, with smoke lofting into the stratosphere, a region of the atmosphere beginning around 43,000 feet (13,000 m) above sea level at Kuwait, resulting in global effects and that he believed the net effects would be very similar to the explosion of the Indonesian volcano Tambora in 1815, which resulted in the year 1816 being known as the Year Without a Summer. He reported on initial modeling estimates that forecast impacts extending to south Asia, and perhaps to the northern hemisphere as well. Singer, on the other hand, said that calculations showed that the smoke would go to an altitude of about 3,000 feet (910 m) and then be rained out after about three to five days and thus the lifetime of the smoke would be limited. Both height estimates made by Singer and Sagan turned out to be wrong, albeit with Singer's narrative being closer to what transpired, with the comparatively minimal atmospheric effects remaining limited to the Persian Gulf region, with smoke plumes, in general, lofting to about 10,000 feet (3,000 m) and a few times as high as 20,000 feet (6,100 m). Along with Singer's televised critique, Richard D. Small criticized the initial Nature paper in a reply on March 7, 1991, arguing along similar lines as Singer.
A protein kinase is a kinase which selectively modifies other proteins by covalently adding phosphates to them (phosphorylation) as opposed to kinases which modify lipids, carbohydrates, or other molecules. Phosphorylation usually results in a functional change of the target protein (substrate) by changing enzyme activity, cellular location, or association with other proteins. The human genome contains about 500 protein kinase genes and they constitute about 2% of all human genes. There are two main types of protein kinase. The great majority are serine/threonine kinases, which phosphorylate the hydroxyl groups of serines and threonines in their targets. Most of the others are tyrosine kinases, although additional types exist. Protein kinases are also found in bacteria and plants. Up to 30% of all human proteins may be modified by kinase activity, and kinases are known to regulate the majority of cellular pathways, especially those involved in signal transduction.
Sources: en.wikipedia.org
American Solidarity Party: Peter Sonski, Connecticut school board member Approval Voting Party: Blake Huber, activist and nominee for president in 2020 Constitution Party: Randall Terry, anti-abortion activist and perennial candidate Independent American Party: Joel Skousen, survivalist and consultant Natural Law Party: Robert F. Kennedy Jr., environmental lawyer and author, the party's nominee in addition to his run as an independent before he withdrew from the race ahead of the election but was not removed from ballots Party for Socialism and Liberation: Claudia De la Cruz, political activist Prohibition Party: Michael Wood, businessman Socialist Equality Party: Joseph Kishore, writer and SEP nominee in 2020 Socialist Party USA: Bill Stodden, nonprofit executive Socialist Workers Party: Rachele Fruit, hotel worker and trade unionist
Having witnessed the crucial role of space to United States military success in the Gulf War, China continues to view space as a critical domain in both conflict and international strategic competition. The PLA operates a various satellite constellations performing reconnaissance, navigation, communication, and counterspace functions. Planners at PLA's National Defense University project China's space actions as retaliatory or preventative, following conditions like an attack on a Chinese satellite, an attack on China, or the interruption of a PLA amphibious landing. According to this approach, PLA planners assume that the country must have the capacity for retaliation and second-strike capability against a powerful opponent. PLA planners envision a limited space war and therefore seek to identify weak but critical nodes in other space systems. Significant components of the PLA's space-based reconnaissance include Jianbing (vanguard) satellites with cover names Yaogan (遥感; 'remote sensing') and Gaofen (高分; 'high resolution'). These satellites collect electro-optical (EO) imagery to collect a literal representation of a target, synthetic aperture radar (SAR) imagery to penetrate the cloudy climates of southern China, and electronic intelligence (ELINT) to provide targeting intelligence on adversarial ships. The PLA also leverages a restricted, high-performance service of the country's BeiDou positioning, navigation, and timing (PNT) satellites for its forces and intelligence, surveillance, and reconnaissance (ISR) platforms.
); rather, it depends on the orchestrated activity of SOM components. The distinct spatial distribution of these proteins—observed both on coral skeletons and in coral cell cultures—underscores their specific and diverse roles in directing crystal nucleation, growth, and overall skeletal architecture.
=== Alcoholism === Research in animal models and clinical studies in alcoholic patients have found that tiapride has anxiolytic effects. Dopamine hyperactivity has been linked with alcohol withdrawal syndrome (AWS), suggesting that tiapride's antidopaminergic effects are the most likely mechanism for its clinical efficacy, although others believe some other mechanism might be involved. Alcoholic patients treated with tiapride at a dosage of 300 mg/day reported reduced psychological distress and improved abstinence from alcohol. In another study in which alcoholic patients were given titrated doses up to 800 mg/day, subjects showed significant improvements in ratings of withdrawal, craving, psychiatric symptoms and quality of life. While tiapride does not affect positive symptoms of psychosis such as hallucinosis or delirium sometimes manifested in alcohol withdrawal syndrome, if combined with a drug such as carbamazepine that addresses those symptoms, it is ideal for treating alcohol dependency because its metabolism does not depend on liver function and it has low potential for abuse. This sets it apart from the benzodiazepines, which are contraindicated with alcohol and can be addictive. Moreover, tiapride's rapid onset makes intravenous or intramuscular injection prior to or during withdrawal episodes particularly effective.
== Career == In 1979, Weber joined the Department of Chemistry at the University of Pittsburgh, where he is currently a Professor of Chemistry and Clinical Translational Science. He has served in a number of capacities at the university, including becoming Director of Graduate Studies for the Chemistry Department in 2001. He has published over 200 journal articles, and has served on the editorial boards of Analytical Chemistry, Trends in Analytical Chemistry and the Journal of Chromatography.
Sources: en.wikipedia.org
Yes, the terms are generally interchangeable. Lyophilization is more common in pharmaceutical and laboratory contexts, while freeze-drying appears widely in food science and general writing. Both describe removal of solvent by sublimation under vacuum after freezing.
Reduced pressure keeps the process below the triple point of water, so ice can sublimate directly to vapor. It also lowers the temperature needed for drying, which helps preserve heat-sensitive materials. Without vacuum, melting or boiling could occur instead of controlled sublimation.
The rate depends on heat transfer to the product and mass transfer of vapor through the dried layer. A cold condenser, adequate vacuum, and suitable shelf temperature all influence speed. Formulation properties such as solid content and collapse temperature also set practical limits.
Freezing only converts liquid to solid. Lyophilization adds vacuum and controlled warming so frozen solvent sublimes, leaving a dry porous solid. The two steps are related but not interchangeable.