A practical reference on secondary drying: what it is, how it behaves, what the literature reports, and where the honest uncertainties sit.
Reviewed 2026-06-22. Anything still debated is marked as such rather than presented as settled.
A typical cycle begins with freezing, sometimes including an annealing step to control ice crystal size. Freezing conditions influence the pore network that later allows vapor escape. During primary drying, shelf temperature and chamber pressure are set so heat enters the product while its temperature stays below the collapse or eutectic point. Secondary drying then raises the shelf temperature to desorb bound water and lower residual moisture. Cycle design depends on formulation, fill volume, container type, and equipment capability.
The physics of lyophilization couples heat transfer, mass transfer, and phase behavior. Sublimation requires a vapor pressure difference between the ice front and the chamber, and the dried layer adds resistance to vapor flow. Amorphous formulations are characterized by a glass transition temperature of the maximally freeze-concentrated solute, often denoted Tg'. Crystalline bulking agents can provide structure, while amorphous excipients stabilize labile components. Open questions remain about spatial heterogeneity, edge effects, and how laboratory cycles scale to production.
Lyophilization is a drying process in which a solvent, usually water, is removed from a frozen material by sublimation under reduced pressure. The material is first solidified, then placed under vacuum so that ice transitions directly to vapor without a bulk liquid phase. This approach suits heat-sensitive substances that would degrade during conventional evaporation. Primary drying removes unbound ice, while secondary drying reduces water that remains adsorbed to the solid matrix. The result is a porous, lightweight solid that can be reconstituted later.
Freeze-drying is distinct from simple evaporation and from spray drying. Evaporation removes water at temperatures above freezing, while spray drying rapidly dries droplets in a heated gas stream. Lyophilization avoids high temperatures, which can be useful for heat-sensitive materials such as proteins, vaccines, and some foods. The porous cake produced by sublimation dissolves or rehydrates more quickly than a dense dried mass. Not all materials tolerate freezing or the pH shifts that can occur as solutes concentrate during ice formation.
Lyophilization removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts liquid water into ice and fixes the structure of the sample. After freezing, primary drying lowers pressure so ice changes directly to vapor without passing through a liquid phase. Secondary drying then removes bound water that remains after ice sublimation. The result is a dry, porous solid that often retains its original shape.
| Property | Value | Notes |
|---|---|---|
| Physical state | Solid, porous cake or powder | Depends on formulation and container |
| Typical storage temperature | 2–25 °C, protected from moisture | Some materials require colder conditions |
| Solubility class | Usually readily soluble after reconstitution | Not an intrinsic chemical property |
| Common analytical method | Karl Fischer titration | Used for residual moisture |
| Common synonyms | Freeze-drying; lyophilisation | Lyophilisation is a spelling variant |
Formulation composition influences whether freeze-drying produces an intact cake or a collapsed mass. Excipients such as sugars and polymers can raise the collapse temperature and provide bulk during drying. The critical temperature for primary drying is often the collapse temperature or the glass transition temperature of the maximally concentrated phase. If the product temperature exceeds this threshold, the frozen matrix may soften and lose structure. Established practice therefore links shelf temperature and chamber pressure to the formulation's thermal properties.
The physics of freeze-drying couples heat transfer, mass transfer, and phase change. Heat supplied through the shelf must reach the sublimation front without melting the ice or degrading the product. Water vapor then travels through the already dried layer and leaves the chamber, where low pressure and cold traps keep it from returning. The dried layer acts as a resistance to vapor flow, so drying rate changes as the front recedes. Open questions remain about how pore structure and formulation heterogeneity affect drying uniformity at larger scales.
In practice, lyophilization is slower and more energy intensive than simple drying. Cycle times can range from hours to several days depending on load, container, and formulation. Amorphous materials may require excipients that help preserve structure during freezing and drying. The method is widely used for biological materials, pharmaceuticals, and foods where heat drying would cause unacceptable change. Open questions remain about scaling cycles between laboratory and production equipment, and this gap affects technology transfer.
Lyophilization removes water by freezing a material and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intermediate liquid state. Because the material remains frozen during primary drying, the structure often stays porous. This porous matrix can rehydrate quickly when water is added back. The low pressure also allows vapor to leave the solid matrix without boiling.
Freezing is the first stage and sets the ice structure that later becomes the pore network. The formulation is cooled below its freezing point, often with a controlled ramp, and solutes concentrate as ice forms. Primary drying then lowers chamber pressure and supplies heat to sublime the ice. The product temperature must stay below its collapse or eutectic temperature to prevent structural loss. Secondary drying raises the temperature modestly to remove bound water and achieve a low residual moisture.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
Industries use lyophilization for pharmaceuticals, biological products, and food preservation. In the pharmaceutical sector, it extends the shelf life of injectable drugs, vaccines, and proteins that are unstable in aqueous solution. Food manufacturers apply freeze-drying to coffee, fruits, and ready meals to retain flavor and texture. The process is energy-intensive and requires specialized equipment, which limits its use to high-value products. Ongoing research examines how formulation and process parameters affect the quality of the final dried product.
Lyophilization, also known as freeze-drying, is a process that removes water from a material by freezing it and then reducing pressure to allow ice to sublimate directly into vapor. The method begins with a freezing step that solidifies the water content. Next, primary drying lowers the pressure below the triple point of water, enabling sublimation without passing through a liquid phase. A final secondary drying step removes bound water through desorption. This sequence produces a dry, porous cake that can be reconstituted later.
Stephanie Kate Howard, Moves and Operations Manager, Buckingham Palace Re-servicing Programme, Royal Household. Adelaide Georgina Gray Izat, Paintings Conservator, Royal Collection, Royal Household. Daniel James Kevin Johnson, Archbishop of Canterbury's Coronation Planning Director, on the occasion of the Coronation of Their Majesties The King and The Queen. Kevin Malkin, Detective Constable, Metropolitan Police Service. For services to Royalty Protection. Louise Michelle Walker-Pickett, Purchasing and Cost Control Co- ordinator, Royal Household. Nicola Jane Pritchard, Property Project Manager, Windsor Castle. Warrant Officer Class 1 David Alexander Roper, Grenadier Guards, 25131200; Superintending Clerk, Household Division, on the occasion of the Coronation of Their Majesties The King and The Queen. Warrant Officer Class 2 Julian Philip Desmond Sandford, Royal Corps of Army Music, 25152991; Sergeant Major, Band of the Household Cavalry, on the occasion of the Coronation of Their Majesties The King and The Queen. Christopher Charles Savage, lately Messenger Sergeant Major, The King's Body Guard of the Yeomen of the Guard. Derrick Andrew Scott, Royal Borough of Windsor and Maidenhead, on the occasion of the Coronation Concert. Thomas Nicholas McKinlay Service, lately Acting Chief Operating Officer, Household of The Prince and Princess of Wales. Elizabeth Fiona St Clair, Sergeant, Metropolitan Police Service. For services to Royalty and Specialist Protection. Kathryn Elizabeth Stone, Paper Conservator, Royal Collection, Royal Household.
in medicine, forming nouns with the sense "swelling, tumour" in botany or zoology, forming nouns in the sense "a part of an animal or plant with a specified structure" in cellular and molecular biology, forming nouns with the sense "all constituents considered collectively" The -ome suffix originated as a variant of -oma, and became productive in the last quarter of the 19th century. It originally appeared in terms like sclerome or rhizome. All of these terms derive from Greek words in -ωμα, a sequence that is not a single suffix, but analyzable as -ω-μα, the -ω- belonging to the word stem (usually a verb) and the -μα being a genuine Greek suffix forming abstract nouns. The OED suggests that its third definition originated as a back-formation from mitome, Early attestations include biome (1916) and genome (first coined as German Genom in 1920). The association with chromosome in molecular biology is by false etymology. The word chromosome derives from the Greek stems χρωμ(ατ)- "colour" and σωμ(ατ)- "body". While σωμα "body" genuinely contains the -μα suffix, the preceding -ω- is not a stem-forming suffix but part of the word's root. Because genome refers to the complete genetic makeup of an organism, a neo-suffix -ome suggested itself as referring to "wholeness" or "completion". Bioinformaticians and molecular biologists figured amongst the first scientists to apply the "-ome" suffix widely.
In February 2022, journalist Marwan Bishara held the US and Russia responsible for pursuing "their own narrow interests", including then-US president Trump's recognition of Jerusalem as capital of Israel as well as Putin's Russian invasion of Ukraine, and for "pav[ing] the way for, well, another Cold War".
Other winemakers may allow the wild yeasts to continue fermenting until they succumb to the toxicity of the alcohol they produce which is often between 3–5% alcohol by volume and then letting either inoculated or "ambient" Saccharomyces strains finish the fermentation.
== General sources == Aniszewski, Tadeusz (2007). Alkaloids: secrets of life. Amsterdam: Elsevier. ISBN 978-0-444-52736-3. Begley, Tadhg P. (2009). Encyclopedia of Chemical Biology. Vol. 10. Wiley. pp. 1569–1570. doi:10.1002/cbic.200900262. ISBN 978-0-471-75477-0. Brossi, Arnold (1989). The Alkaloids: Chemistry and Pharmacology. Academic Press. Dewick, Paul M. (2002). Medicinal Natural Products: A Biosynthetic Approach (Second ed.). Wiley. ISBN 978-0-471-49640-3. Fattorusso, E.; Taglialatela-Scafati, O. (2008). Modern Alkaloids: Structure, Isolation, Synthesis and Biology. Wiley-VCH. ISBN 978-3-527-31521-5. Grinkevich NI; Safronich LN, eds. (1983). The chemical analysis of medicinal plants (in Russian). Moscow: Vysshaya Shkola. Hesse, Manfred (2002). Alkaloids: Nature's Curse or Blessing?. Wiley-VCH. ISBN 978-3-906390-24-6. Knunyants, IL (1988). Chemical Encyclopedia. Soviet Encyclopedia. Orekhov, AP (1955). Chemistry alkaloids (Acad. 2nd ed.). Moscow.{{cite book}}: CS1 maint: location missing publisher (link) Plemenkov, VV (2001). Introduction to the Chemistry of Natural Compounds. Kazan.{{cite book}}: CS1 maint: location missing publisher (link) Saxton, J. E. (1971). The Alkaloids: A Specialist Periodical Report. London: The Chemical Society. Veselovskaya, N. B.; Kovalenko, A. E. (2000). Drugs. Moscow: Triada-X. Wink, M (2009). "Mode of action and toxicology of plant toxins and poisonous plants". Mitt. Julius Kühn-Inst. 421: 93–112x.
Sources: en.wikipedia.org
== Cuisine == Wakame fronds are green and have a subtly sweet flavour and satiny texture. The leaves should be cut into small pieces as they will expand during cooking. In Japan and Europe, wakame is distributed either dried or salted, and used in soups (particularly miso soup), and salads (tofu salad), or often simply as a side dish to tofu and a salad vegetable like cucumber. These dishes are typically dressed with soya sauce and vinegar, possibly rice vinegar. Goma wakame, also known as seaweed salad, is a popular side dish at American and European sushi restaurants. Literally, it means "sesame seaweed", as sesame seeds are usually included in the recipe. In Korea, wakame is used to make a seaweed soup called miyeok-guk, in which wakame is stir-fried in sesame oil and boiled with meat broth.
planifolia seeds this way are Eulaema polychroma and Scaptotrigona subobscuripennis. Seeds being distributed by bees is a rare behavior and has only been documented in three species of tropical trees previously, the cadaghi (Corymbia torelliana), Coussapoa asperifolia subsp. magnifolia, and Zygia racemosa. Both rodents and marsupials are confirmed to consume fallen pods on the forest floor. Specific species observed eating the pods include Tome's spiny rat (Proechimys semispinosus) and the common opossum (Didelphis marsupialis). Further experiments by a team led by Dr. Adam Karremans showed that the seeds remained viable after being passed through the mammalian gut, but it did not increase or decrease germination significantly.
=== Impact of research === Every form of eukaryotic life on earth contains coated vesicles and adaptors. Her work is also speculated to play a key role in evolution of eukaryotes form prokaryotes over two billion years ago. Her work also has medical implications. Some adaptors are mutated in certain genetic disorders, and adaptors are frequently exploited by pathogens . For example, the HIV genome encodes a protein called Nef, which is required for the development of AIDS, and which works by hijacking adaptors and using them to modify the surface of the infected cell. Robinson's work explains how coated vesicles sort cargo but also provides tools that can be used by others to address their own favorite problems. For instance, her newly developed method called knocksideways. Knocksideways gets rid of proteins rapidly. Her technique has found its way into other labs who are also interested in how particular proteins contribute to different stages of cell division.
coordination complex A chemical compound consisting of a central atom or ion, usually metallic and known as the coordination center, bonded to a surrounding array of other groups of atoms, e.g. molecules or ions, which are known as ligands or complexing agents. Many metal-containing compounds, especially those of the transition metals, are coordination complexes. See also complex.
Sources: en.wikipedia.org
The opposite property to ionisation energy is the electron affinity, which is the energy released when adding an electron to the atom. A passing electron will be more readily attracted to an atom if it feels the pull of the nucleus more strongly, and especially if there is an available partially filled outer orbital that can accommodate it. Therefore, electron affinity tends to increase down to up and left to right. The exception is the last column, the noble gases, which have a full shell and have no room for another electron. This gives the halogens in the next-to-last column the highest electron affinities. Some atoms, like the noble gases, have no electron affinity: they cannot form stable gas-phase anions. (They can form metastable resonances if the incoming electron arrives with enough kinetic energy, but these inevitably and rapidly autodetach: for example, the lifetime of the most long-lived He− level is about 359 microseconds.) The noble gases, having high ionisation energies and no electron affinity, have little inclination towards gaining or losing electrons and are generally unreactive. Some exceptions to the trends occur: oxygen and fluorine have lower electron affinities than their heavier homologues sulfur and chlorine, because they are small atoms and hence the newly added electron would experience significant repulsion from the already present ones. For the nonmetallic elements, electron affinity likewise somewhat correlates with reactivity, but not perfectly since other factors are involved.
The mummies of the Canary Islands belong to the indigenous Guanche people and date to the time before 14th-century Spanish explorers settled in the area. All deceased people within the Guanche culture were mummified during this time, though the level of care taken with embalming and burial varied depending on individual social status. Embalming was carried out by specialized groups, organized according to gender, who were considered unclean by the rest of the community. The techniques for embalming were similar to those of the ancient Egyptians, involving evisceration, preservation, and stuffing of the evacuated bodily cavities, then wrapping the body in animal skins. Despite the successful techniques utilized by the Guanche, very few mummies remain due to looting and desecration.
As the number of confirmed COVID-19 cases in the state continued to rise, on March 15, Newsom urged people 65 and older and those with chronic health conditions to isolate themselves from others. He also called on bars and brewery and winery tasting rooms to close their doors to patrons. Some local jurisdictions had mandatory closures. The closures were extended to movie theaters and health clubs. He asked restaurants to stop serving meals inside their establishments and offer take-out meals only. His statewide stay-at-home order became mandatory on March 19. It limited in-house gatherings, including religious gatherings and Bible studies. It allowed movement outside the home for necessities or recreation, but people were required to maintain a safe distance apart. Activity "needed to maintain continuity of operation of the federal critical infrastructure sectors, critical government services, schools, childcare, and construction" was excluded from the order. Essential services such as grocery stores and pharmacies remained open. Newsom provided state funds to pay for protective measures such as hotel room lodging for hospital and other essential workers fearing returning home and infecting family members. By April 26, he had issued 30 executive orders under the state of emergency while the legislature had not been in session. On April 28, Newsom and the governors of Oregon and Washington announced a "shared approach" for reopening their economies.
=== Medium of instruction === At primary and secondary school levels, the government maintains a policy of "mother tongue instruction"; most schools use Cantonese as the medium of instruction, with written education in both Chinese and English. Other languages being used as the medium of instruction in non-international school education include English and Putonghua (Mandarin Chinese). Secondary schools emphasise "bi-literacy and tri-lingualism", which has encouraged the proliferation of spoken Mandarin language education. English is the official medium of instruction and assessment for most university programmes in Hong Kong, although Cantonese is predominant in informal discussions among local students and professors.
Amnesty International stated the following month that the Salvadoran government had committed "massive human rights violations", including torture, against prisoners. In June 2024, Bukele told Time that the security situation in El Salvador had become sustainable and that he and his government hoped to end the state of emergency "in the near future". By 4 March 2025, the state of exception had been extended 36 times by the Legislative Assembly. By that same date, over 85,000 suspected gang members had been arrested, 3,319 of whom were minors according to Human Rights Watch. The large-scale arrests increased El Salvador's prison population from 37,190 in 2020 to over 105,000 by December 2023. With 1.7 percent of its population in prison, El Salvador has the highest incarceration rate in the world. By November 2024, more than 8,000 people had been released after the government determined that they were innocent. According to human rights organizations, at least 367 people had died in custody by March 2025. A number of opinion polls between May 2022 and June 2023 indicated that 80 to 90 percent of Salvadorans approved of the gang crackdown and measures taken by the government against the gangs.
Sources: en.wikipedia.org
Freezing only converts liquid to solid. Lyophilization adds vacuum and controlled warming so frozen solvent sublimes, leaving a dry porous solid. The two steps are related but not interchangeable.
Reduced pressure keeps the solvent below its triple point, allowing ice to become vapor without melting. Vacuum also helps remove water vapor from the product chamber. The exact pressure is chosen with the formulation and equipment.
Residual moisture is water that remains in the dried solid after secondary drying. It is often measured by Karl Fischer titration, near-infrared spectroscopy, or thermogravimetry. Acceptable levels depend on the material and its stability profile.
Lyophilization relies on sublimation, so water moves from solid ice to vapor without becoming liquid. The material is frozen, pressure is reduced, and controlled heat is supplied. Vapor is captured on a cold condenser, leaving a dry porous solid.