primary drying comes up often in conversation and rarely with the context attached. Here we lay out the basics in order, then work through the practical considerations.
Last reviewed on 2025-12-02. Where a claim depends on a specific study, the study is described rather than over-claimed.
Lyophilization, or freeze-drying, removes water from a material by freezing it and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intervening liquid state. It is used for heat-sensitive materials that would degrade in conventional drying. The three stages are freezing, primary drying, and secondary drying, each with distinct temperature and pressure requirements. In practice, cycle design balances these variables.
Freezing determines ice crystal structure and pore size, which affect drying speed and product uniformity. Rapid freezing creates small crystals, while slow freezing creates larger crystals and often faster sublimation. During primary drying, chamber pressure is held below the vapor pressure of ice, and shelf temperature supplies heat for sublimation. The ice front recedes, leaving a porous matrix. Thermal limits such as collapse and eutectic temperatures set safe boundaries for formulation. These limits vary with solute composition and concentration.
Freezing is the first stage and sets the ice structure that later becomes the pore network. The formulation is cooled below its freezing point, often with a controlled ramp, and solutes concentrate as ice forms. Primary drying then lowers chamber pressure and supplies heat to sublime the ice. The product temperature must stay below its collapse or eutectic temperature to prevent structural loss. Secondary drying raises the temperature modestly to remove bound water and achieve a low residual moisture.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
| Property | Value | Notes |
|---|---|---|
| Process name | Lyophilization or freeze-drying | Both terms appear in technical standards and literature. |
| Phase transition | Sublimation | Solid ice becomes vapor without a liquid step. |
| Typical chamber pressure | 0.05-0.5 mbar | Range depends on product temperature and equipment. |
| Typical product temperature | -40 °C to -10 °C | Measured during primary drying; formulation sets limits. |
| Water content after drying | 0.5-3% w/w | Target varies by material and stability needs. |
A formulation often contains excipients that protect the active ingredient during freezing and drying. Bulking agents provide structure, while lyoprotectants stabilize sensitive molecules. The freezing step can produce ice crystals whose size and distribution affect the drying rate, and cycle design includes freezing, annealing, and drying phases. If the product temperature rises above a critical value, the cake may collapse or lose its porous structure. Successful lyophilization therefore depends on the interaction between formulation, equipment, and cycle design.
Lyophilization is a dehydration process that removes water from a frozen material by sublimation under low pressure. The material is first frozen to convert liquid water into ice. Next, the pressure is reduced below the triple point of water so that ice changes directly into vapor without passing through a liquid phase. This step is called primary drying. The result is a porous solid or cake that retains the original shape of the frozen solution.
After primary drying, secondary drying removes water that remains bound to the material. This stage raises the shelf temperature while maintaining low pressure, which encourages desorption of unfrozen water. Residual moisture can be reduced to a low percentage, improving stability for many products. The process parameters, including freezing rate, shelf temperature, and chamber pressure, influence the final pore structure and reconstitution behavior. Control of these variables helps prevent collapse or meltback during drying.
Industries use lyophilization for pharmaceuticals, biological products, and food preservation. In the pharmaceutical sector, it extends the shelf life of injectable drugs, vaccines, and proteins that are unstable in aqueous solution. Food manufacturers apply freeze-drying to coffee, fruits, and ready meals to retain flavor and texture. The process is energy-intensive and requires specialized equipment, which limits its use to high-value products. Ongoing research examines how formulation and process parameters affect the quality of the final dried product.
Lyophilization, also known as freeze-drying, is a process that removes water from a material by freezing it and then reducing pressure to allow ice to sublimate directly into vapor. The method begins with a freezing step that solidifies the water content. Next, primary drying lowers the pressure below the triple point of water, enabling sublimation without passing through a liquid phase. A final secondary drying step removes bound water through desorption. This sequence produces a dry, porous cake that can be reconstituted later.
The news media focused on Nixon's militaristic tone, describing his announcement with variations of the phrase "war on drugs". The day after Nixon's press conference, the Chicago Tribune proclaimed, "Nixon Declares War on Narcotics Use in US". In England, The Guardian headlined, "Nixon declares war on drug addicts." The US anti-drug campaign came to be commonly referred to as the war on drugs; the term also became used to refer to any government's prosecution of a US-style prohibition-based drug policy. Facing reelection, with drug control as a campaign centerpiece, Nixon formed the Office of Drug Abuse Law Enforcement (ODALE) in late 1971. ODALE, armed with new federal enforcement powers, began orchestrating drug raids nationwide to improve the administration's watchdog reputation. In a private conversation while helicoptering over Brooklyn, Nixon was reported to have commented, "You and I care about treatment. But those people down there, they want those criminals off the streets." From 1972 to 1973, ODALE performed 6,000 drug arrests in 18 months, the majority of the arrested black. In 1972, the Shafer Commission released its report, "Marihuana: A Signal of Misunderstanding", comprising a review of the medical literature and a national drug survey. It recommended decriminalization for personal possession and use of small amounts of cannabis, and prohibition only of supply. The conclusion was not acted on by Nixon or by Congress.
== A == ADI – Ambient desorption ionization AE – Appearance energy AFADESI – Air flow-assisted desorption electrospray ionization AFAI – Air flow-assisted ionization AFAPA – Aerosol flowing atmospheric-pressure afterglow AGHIS – All-glass heated inlet system AIRLAB – Ambient infrared laser ablation AMS – Accelerator mass spectrometry AMS – Aerosol mass spectrometer AMU – Atomic mass unit AP – Appearance potential AP MALDI – Atmospheric pressure matrix-assisted laser desorption/ionization APCI – Atmospheric pressure chemical ionization API – Atmospheric pressure ionization APPI – Atmospheric pressure photoionization ASAP – Atmospheric Sample Analysis Probe ASMS – American Society for Mass Spectrometry
=== Pharmacodynamics === NBOMe-LAD is known to act as an agonist of the serotonin 5-HT2A receptor and to interact with other receptors, but shows dramatically reduced potency compared to LSD in vitro. At the serotonin 5-HT2A receptor, it had 37-fold lower affinity, 148-fold lower activational potency in terms of calcium release, and around half the maximal efficacy in terms of calcium release relative to LSD. On the other hand, NBOMe-LAD had only about 4-fold lower potency in terms of β-arrestin recruitment along with similar activational efficacy for this pathway relative to LSD. NBOMe-LAD produces the head-twitch response, a behavioral proxy of psychedelic effects, in rodents, but with greatly reduced potency and maximal efficacy relative to PRO-LAD and analogues. Its ED50Tooltip median effective dose for inducing the head-twitch response was 13-fold lower than that of PRO-LAD and its maximal effect was about one-third that of PRO-LAD. However, the most efficacious dose of NBOMe-LAD was 3.2 mg/kg whereas that of PRO-LAD was 1 mg/kg.
In iatrogenic cases of hypersomatotropism, when the condition is caused by administered progestogens, the typical features of acromegaly occur; however, glucose tolerance is maintained initially by increased insulin levels, eventually insulin levels cannot be increased any further and glucose intolerance occurs. Most abnormalities are reversible after cessation of treatment; however, bone lesions may be permanent. Increase in growth hormone and IGF-1 levels in bitches is a physiological event that occurs during the luteal phase of the oestrous cycle. In bitches with spontaneous acromegaly brought on by oestrous, their progesterone levels are normal; however, growth hormone levels are increased. Recovery following an ovariohysterectomy may be possible. The reason as to why some bitches develop acromegaly and diabetes mellitus during the oestrous cycle is unknown.
Sources: en.wikipedia.org
== External links == Jeffries WB (1999-02-17). "Inverse Agonists for Medical Students". Office of Medical Education - Courses - IDC 105 Principles of Pharmacology. Creighton University School of Medicine - Department of Pharmacology. Retrieved 2008-08-12. Inverse Agonists: An Illustrated Tutorial Panesar K, Guzman F. Pharmacology Corner. 2012
== Misattributed == Teleny, or The Reverse of the Medal (Paris, 1893) has been attributed to Wilde, but its authorship is unclear. One theory is that it was a combined effort by several of Wilde's friends, which he may have edited. Constance – On September 14, 2011, Wilde's grandson Merlin Holland contested Wilde's claimed authorship of this play entitled Constance, scheduled to open that week in the King's Head Theatre. It was not, in fact, "Oscar Wilde's final play," as its producers were claiming. Holland said Wilde did sketch out the play's scenario in 1894, but "never wrote a word" of it, and that "it is dishonest to foist this on the public." The artistic director Adam Spreadbury-Maher of the King's Head Theatre and producer of Constance pointed out that Wilde's son, Vyvyan Holland, wrote, in 1954, "a significant amount of the dialogue (of Constance) bears the authentic stamp of my father's hand". There is further proof that the developed scenario that Constance was reconstituted from was written by Wilde between 1897 and his death in 1900, rather than the 1894 George Alexander scenario which Merlin Holland quotes.
Both of these positions were abolished again by the 1988 coup d'etat in which the State Law and Order Restoration Council replaced them. The SLORC was abolished and the junta was reconstituted as the State Peace and Development Council in 1997. During the 1988–2011 period, no president was appointed and the chairman of the junta assumed the position of head of state. The 2008 Constitution introduced the presidential system, in which the "President" is both the head of state and the head of government. This presidential system was adopted upon the inauguration of former prime minister retired general U Thein Sein as the first president under 2008 Constitution in 2011. In 2021 coup d'état, the then vice-president assumed the title "Pro Tem (President)", called the National Defence and Security Council and proclaimed a nation-wide state of emergency, transferring the powers of executive, legislative and judiciary to the Commander-in-Chief of Defence Services. In 2024, citing health reason, the "Pro Tem President" transferred his powers related to the National Defence and Security to the Commander-in-Chief of Defence Services who used the title "Pro Tem President (On Duty)" from then onward until early 2026 when he started to use the title Acting President instead. After he was elected as the president, he used both the titles "President-elect" and "Acting President" until he was officially sworn in as the "President".
Active transport of carbapenem drugs out of the cell, augmented drug efflux, has been observed in some resistant species. One mechanism of resistance is mutation in or loss of outer membrane porins, preventing antibiotics from entering the cells. Changes within the porin protein gene cause a frameshift, altering the porin structure and function. Changes in the porin protein hinder the diffusion of carbapenem and other antibiotics into the periplasm. Bacteria that express plasmid-borne extended-spectrum β-lactamases (ESBL) can become carbapenem-resistant if an insertion sequence or four-nucleotide duplication is present within chromosomal genes for outer membrane porin proteins. Klebsiella pneumoniae has been associated with the lack of outer membrane porin proteins, OmpK35 and OmpK36. The loss of OmpK36 porins can be attributed to point mutations that result in premature termination of translation, resulting in a truncated and consequently nonfunctional protein. These outer membrane proteins are involved in the transfer of the antimicrobial genetic material in the cell. Loss of either OmpK35 and OmpK36 or only OmpK36 leads to carbapenem resistance. In Klebsiella pneumoniae, the lack of either OmpK35 or OmpK36 leads to carbapenem resistance, but with the lack of both proteins, a high level of resistance is present. An observed 32- to 64-fold increase in minimum inhibitory concentrations occurs for the carbapenems when both proteins are not expressed. CRE produce carbapenemases, a form of β-lactamase.
== Etymology == Paul Ehrlich coined the term antibody (German: Antikörper) in his side-chain theory at the end of the 19th century. In 1899, Ladislas Deutsch (László Detre) named the hypothetical substances halfway between bacterial constituents and antibodies "antigenic or immunogenic substances" (French: substances immunogènes ou antigènes). He originally believed those substances to be precursors of antibodies, just as a zymogen is a precursor of an enzyme. But, by 1903, he understood that an antigen induces the production of immune bodies (antibodies) and wrote that the word antigen is a contraction of antisomatogen (Immunkörperbildner). The Oxford English Dictionary indicates that the logical construction should be "anti(body)-gen". The term originally referred to a substance that acts as an antibody generator.
Sources: en.wikipedia.org
Portugal's African colonial expansion culminated in the 1890 British Ultimatum, which thwarted its ambitions. The ultimatum and the 1891 Anglo-Portuguese Treaty, compounded by existing turmoil, led to political erosion and weakened the monarchy.
== Ecology == The Liliaceae are ecologically diverse. Species of Liliaceae bloom at various times from spring to late summer. The colorful flowers produce large amounts of nectar and pollen that attract insects which pollinate them (entomophily), particularly bees and wasps (hymenopterophily), butterflies (psychophily) and moths (phalaenophily). The seeds are dispersed by wind and water. Some species (e.g. Scoliopus, Erythronium and Gagea) have seeds with an aril structure that are dispersed by ants (myrmecochory). The proliferation of deer populations in many areas, due to human factors such as the elimination of their animal predators and introduction to alien environments, is placing considerable herbivory pressure on many of the family's species. Fences as high as 8 feet may be required to prevent them from consuming the plants, an impractical solution for most wild areas. Those of the genus Lilium are particularly palatable, while species in Fritillaria are repellant.
gene expression The set of processes by which the information encoded in a gene is used in the synthesis of a gene product, such as a protein or a non-coding RNA, or otherwise made available to influence one or more phenotypes; both the product and the gene encoding it are then said to be expressed. Canonically, the first step is transcription, which produces a messenger RNA molecule complementary to the DNA molecule in which the gene is encoded. For protein-coding genes, the second step is translation, in which the messenger RNA is read by a ribosome to produce a polypeptide and ultimately a protein. The information contained within a DNA sequence need not necessarily be transcribed and translated to exert an influence on molecular events, however: broader definitions encompass a huge variety of other ways in which genetic information can be expressed.
subsequently found that HClO destroys cytochromes and iron-sulfur clusters and observed that oxygen uptake is abolished by HClO and adenine nucleotides are lost. It was also observed that irreversible oxidation of cytochromes paralleled the loss of respiratory activity. One way of addressing the loss of oxygen uptake was by studying the effects of HClO on succinate-dependent electron transport. Rosen et al. found that levels of reductable cytochromes in HClO-treated cells were normal, and these cells were unable to reduce them. Succinate dehydrogenase was also inhibited by HClO, stopping the flow of electrons to oxygen. Later studies revealed that Ubiquinol oxidase activity ceases first, and the still-active cytochromes reduce the remaining quinone. The cytochromes then pass the electrons to oxygen, which explains why the cytochromes cannot be reoxidized, as observed by Rosen et al. However, this line of inquiry was ended when Albrich et al. found that cellular inactivation precedes loss of respiration by using a flow mixing system that allowed evaluation of viability on much smaller time scales. This group found that cells capable of respiring could not divide after exposure to HClO.
The antibody selectively binds to protein A/G, so a high level of purity (generally >80%) is obtained. The generally harsh conditions of this method may damage easily damaged antibodies. A low pH can break the bonds to remove the antibody from the column. In addition to possibly affecting the product, low pH can cause protein A/G itself to leak off the column and appear in the eluted sample. Gentle elution buffer systems that employ high salt concentrations are available to avoid exposing sensitive antibodies to low pH. Cost is also an important consideration with this method because immobilized protein A/G is a more expensive resin. To achieve maximum purity in a single step, affinity purification can be performed, using the antigen to provide specificity for the antibody. In this method, the antigen used to generate the antibody is covalently attached to an agarose support. If the antigen is a peptide, it is commonly synthesized with a terminal cysteine, which allows selective attachment to a carrier protein, such as KLH during development and to support purification. The antibody-containing medium is then incubated with the immobilized antigen, either in batch or as the antibody is passed through a column, where it selectively binds and can be retained while impurities are washed away. An elution with a low pH buffer or a more gentle, high salt elution buffer is then used to recover purified antibody from the support.
Sources: en.wikipedia.org
Conventional drying uses heat to evaporate liquid water, often at temperatures that can degrade sensitive materials. Lyophilization freezes the material first and then removes water by sublimation under vacuum. This avoids prolonged exposure to liquid water and high heat.
Lowering pressure reduces the boiling point of water and allows ice to sublimate at temperatures below freezing. Vacuum also limits convective heat transfer, so heat is usually supplied by shelves or radiation. The pressure must stay below the vapor pressure of ice at the product temperature.
The cycle typically includes freezing, primary drying, and secondary drying. Freezing solidifies water and sets the pore structure; primary drying removes bulk ice; secondary drying removes bound water. Some cycles add annealing or pre-freezing steps.
Yes, the terms are generally interchangeable. Lyophilization is more common in pharmaceutical and laboratory contexts, while freeze-drying appears widely in food science and general writing. Both describe removal of solvent by sublimation under vacuum after freezing.