Sublimation raises a handful of sensible questions. This page answers them in order, starting with the fundamentals and moving to applications.
Reviewed 2025-12-11. Anything still debated is marked as such rather than presented as settled.
The physics of freeze-drying couples heat transfer, mass transfer, and phase change. Heat supplied through the shelf must reach the sublimation front without melting the ice or degrading the product. Water vapor then travels through the already dried layer and leaves the chamber, where low pressure and cold traps keep it from returning. The dried layer acts as a resistance to vapor flow, so drying rate changes as the front recedes. Open questions remain about how pore structure and formulation heterogeneity affect drying uniformity at larger scales.
Lyophilization removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts liquid water into ice and concentrates dissolved solids. Primary drying then lowers chamber pressure so ice changes directly into vapor without passing through a liquid phase. Secondary drying raises the shelf temperature to remove bound water that remains after ice sublimation. The result is a dry, porous structure that can be reconstituted later.
Formulation composition influences whether freeze-drying produces an intact cake or a collapsed mass. Excipients such as sugars and polymers can raise the collapse temperature and provide bulk during drying. The critical temperature for primary drying is often the collapse temperature or the glass transition temperature of the maximally concentrated phase. If the product temperature exceeds this threshold, the frozen matrix may soften and lose structure. Established practice therefore links shelf temperature and chamber pressure to the formulation's thermal properties.
A typical cycle begins with freezing, sometimes including an annealing step to control ice crystal size. Freezing conditions influence the pore network that later allows vapor escape. During primary drying, shelf temperature and chamber pressure are set so heat enters the product while its temperature stays below the collapse or eutectic point. Secondary drying then raises the shelf temperature to desorb bound water and lower residual moisture. Cycle design depends on formulation, fill volume, container type, and equipment capability.
The physics of lyophilization couples heat transfer, mass transfer, and phase behavior. Sublimation requires a vapor pressure difference between the ice front and the chamber, and the dried layer adds resistance to vapor flow. Amorphous formulations are characterized by a glass transition temperature of the maximally freeze-concentrated solute, often denoted Tg'. Crystalline bulking agents can provide structure, while amorphous excipients stabilize labile components. Open questions remain about spatial heterogeneity, edge effects, and how laboratory cycles scale to production.
| Property | Value | Notes |
|---|---|---|
| Common name | Freeze-drying | Process removes water by sublimation under vacuum. |
| Typical primary drying shelf temperature | -40 C to -10 C | Set below the formulation's collapse temperature. |
| Typical chamber pressure | 0.05-0.3 mbar | Low pressure allows ice to sublime below its triple point. |
| Water content after drying | 0.5-3% by weight | Higher values may reduce storage stability for some materials. |
| Key thermal parameter | Collapse temperature | Measured by freeze-drying microscopy or differential scanning calorimetry. |
Secondary drying removes bound water that remains after ice sublimation. Shelf temperature is raised gradually while pressure remains low, reducing water content to a target range. Over-drying can cause brittleness or electrostatic issues, while under-drying affects stability. The endpoint is often judged by pressure rise tests, temperature measurements, or water content analysis. Scale-up depends on matching heat and mass transfer across equipment sizes. Small changes in shelf temperature or pressure can alter cycle length substantially.
Lyophilization, or freeze-drying, removes water from a material by freezing it and then lowering pressure so ice changes directly to vapor. The process relies on sublimation, the phase transition from solid to gas without an intervening liquid state. It is used for heat-sensitive materials that would degrade in conventional drying. The three stages are freezing, primary drying, and secondary drying, each with distinct temperature and pressure requirements. In practice, cycle design balances these variables.
Equipment for lyophilization includes a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. A refrigeration system cools the shelves and condenser below the product's freezing point. Process monitoring often uses Pirani and capacitance manometers, thermocouples, and resistance sensors. Cycle development balances product quality with time and energy use. Some products are annealed during freezing to improve crystallization of bulking agents. Open questions remain about scaling cycles between laboratory, pilot, and production freeze-dryers.
Lyophilization, also called freeze-drying, removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts free water into ice and may also produce a glassy phase. Primary drying then lowers chamber pressure so ice sublimes directly to vapor without passing through a liquid stage. Secondary drying raises the temperature modestly to remove bound water. The result is a porous, dry solid that usually reconstitutes quickly. Each stage influences pore structure, residual moisture, and stability.
=== Genetic code engineering === One of the goals of xenobiology is to rewrite the genetic code. The most promising approach to change the code is the reassignment of seldom used or even unused codons. In an ideal scenario, the genetic code is expanded by one codon, thus having been liberated from its old function and fully reassigned to a non-canonical amino acid (ncAA) ("code expansion"). As these methods are laborious to implement, and some short cuts can be applied ("code engineering"), for example in bacteria that are auxotrophic for specific amino acids and at some point in the experiment are fed isostructural analogues instead of the canonical amino acids for which they are auxotrophic. In that situation, the canonical amino acid residues in native proteins are substituted with the ncAAs. Even the insertion of multiple different ncAAs into the same protein is possible. Finally, the repertoire of 20 canonical amino acids can not only be expanded, but also reduced to 19. By reassigning transfer RNA (tRNA)/aminoacyl-tRNA synthetase pairs the codon specificity can be changed. Cells endowed with such aminoacyl-[tRNA synthetases] are thus able to read [mRNA] sequences that make no sense to the existing gene expression machinery. Altering the codon: tRNA synthetases pairs may lead to the in vivo incorporation of the non-canonical amino acids into proteins. In the past reassigning codons was mainly done on a limited scale. In 2013, however, Farren Isaacs and George Church at Harvard University reported the replacement of all 321 TAG stop codons present in the genome of E.
Bryant Park was initially supposed to reopen in late 1990 or early 1991. The reopening date was pushed back due to delays caused by the construction of the library's stacks. In June 1991, the city and BPRC reached an agreement to reopen the western section of Bryant Park on summer weekdays. The park was soft reopened on April 21, 1992, with the official reopening set for nearly a month later. The new design received widespread acclaim. Deemed "a triumph for many" by New York Times architectural critic Paul Goldberger, the renovation was lauded not only for its architectural excellence, but also for adhering to Whyte's vision. According to Goldberger, Biederman "understood that the problem of Bryant Park was its perception as an enclosure cut off from the city; he knew that, paradoxically, people feel safer when not cut off from the city, and that they feel safer in the kind of public space they think they have some control over." The renovation was lauded as "The Best Example of Urban Renewal" by New York magazine, and was described by Time as a "small miracle". Many awards followed, including a Design Merit Award from Landscape Architecture Magazine, and the 1996 Award for Excellence from the Urban Land Institute (ULI). The park has been extolled for its relative calmness and cleanness. Through the 21st century, Bryant Park remained a model of civic renewal that mayors of other cities, such as Jorge Elorza of Providence, Rhode Island, sometimes held up as a model to emulate. Bryant Park was described in the media as an example of New York City's 1990s revival.
== Biography == Palmer was born in Port of Spain on the twin island Republic of Trinidad and Tobago. He is fluent in English and became a U.S. citizen. Palmer earned a chemical engineering degree at Howard University in Washington D.C in 1993 and his doctorate in chemical and biomolecular engineering at Johns Hopkins University in 1998. After completing postdoctoral work at Johns Hopkins University in 1999, Palmer joined the Chemistry Department faculty at Howard University. In 2001, he left for the University of Notre Dame to become assistant professor of chemical and biomolecular engineering. In 2006, after five years, he moved to Ohio State University to become associate professor of chemical and biomolecular engineering, and was promoted to full professor in 2012. He served as interim department chair in 2014–2015. In 2015, he was named Chair of the William G. Lowrie Department of Chemical and Biomolecular Engineering and served until 2019. In March 2020, the Ohio Board of Regents named Palmer, "Ohio Eminent Scholar," a statewide endowed chair. In August 2021, Palmer was appointed Associate Dean for research, charged with directing the College of Engineering's $138 million research enterprise.
== Side effects and withdrawal from market == On April 7, 2005, Pfizer withdrew Bextra from the U.S. market on recommendation by the FDA, citing an increased risk of heart attack and stroke and also the risk of a serious, sometimes fatal, skin reaction. This was a result of recent attention to prescription NSAIDs, such as Merck's Vioxx. Other reported side effects were angina and Stevens–Johnson syndrome. Pfizer first acknowledged cardiovascular risks associated with Bextra in October 2004. The American Heart Association soon after was presented with a report indicating patients using Bextra while recovering from heart surgery were 2.19 times more likely to suffer a stroke or heart attack than those taking placebos. In a large study published in The Journal of the American Medical Association in 2006, valdecoxib appeared less adverse for renal (kidney) disease and heart arrhythmia compared to Vioxx, but elevated renal risks were slightly suggested.
Sources: en.wikipedia.org
Chem. Int. Ed. 2017, 56, 16018-16022. https://doi.org/10.1002/anie.201709463. M, Hifsudheen.; R, K, Mishra.; B, Vedhanarayanan.; V, K, Praveen.; and Ajayaghosh, Ayyappanpillai (2017). “Helix to Super-Helix Transition in p-Systems Self-assembly: Superseding of Molecular Chirality at Hierarchical Level”. Angew. Chem., Int. Ed. 2017, 56, 12634-12638. https://doi.org/10.1002/anie.201707392. S, Ghosh.; S, Cherumukkil.; C, H, Suresh.; and Ajayaghosh, Ayyappanpillai (2017). “A Supramolecular Nanocomposite as Near Infrared Transmitting Optical Filter for Security and Forensic Applications”. Adv. Mater. 2017, 29, 1703783.doi:10.1002/adma.201703783 A, Mal.; R, K, Mishra.; V, K, Praveen.; M, A, Khayum.; R, Banerjee.; and Ajayaghosh, Ayyappanpillai (2018). “Supramolecular Reassembly of Self-Exfoliated Ionic Covalent Organic Nanosheets for Label-Free Detection of dsDNA”. Angew. Chem., Int. Ed. 2018, 57, 8443. https://doi.org/10.1002/anie.201801352. R, D, Mukhopadhyay.; G, Das.; and Ajayaghosh, Ayyappanpillai (2018). “Stepwise Control of Host-Guest Interaction Using a Coordination Polymer Gel”. Nat. Commun. 2018, 9, 1987. https://doi.org/10.1038/s41467-018-04303-8. V, K, Praveen.; B, Vedhanarayanan.; A, Mal.; R, K, Mishra.; and Ajayaghosh Ayyappanpillai (2020). “Self-Assembled Extended p‑Systems for Sensing and Security Applications”. Acc. Chem. Res. 2020, 53, 2, 496-507. https://doi.org/10.1021/acs.accounts.9b00580 S, Chakraborty.; M, M, Joseph.; S, Varughese.; S, Ghosh.; K, K, Maiti.; A, Samanta.; and Ajayaghosh, Ayyappanpillai (2020).
Panic disorder with or without agoraphobia. Body dysmorphic disorder Repetitive self-injurious/self-harming behaviours in those with intellectual disability specifically. The subtype of systemised paranoia characterised by somatic phenomena. Compulsive nail-biting (onychophagia). Cataplexy associated with narcolepsy. This is a TGA and MHRA-labeled indication for clomipramine. Self-bloodletting Premature ejaculation, where it may be more effective than paroxetine Depersonalization-derealization disorder Chronic pain with or without organic disease, particularly headache of the tension type. Developmental stuttering Sleep paralysis, with or without narcolepsy Enuresis (involuntary urinating in sleep) in children. The effect may not be sustained following treatment, and alarm therapy may be more effective in both the short-term and the long-term. Combining a tricyclic (such as clomipramine) with anticholinergic medication may be more effective for treating enuresis than the tricyclic alone. Trichotillomania In combination with lithium and tryptophan for severe, particularly treatment-resistant depression. This combination, in a similar vein, has also been used for clomipramine-resistant obsessive-compulsive disorder. When electro-convulsive therapy is performed alongside this treatment-regime (as may be the case in severe depression and accompanied with thyroxine,) however, great care must be taken with lithium. The overall risk of seizures may have to be weighted against the refractory severity of the current illness and necessity of the amalgamation of treatment(s).
Exorphins are exogenous opioid peptides, distinguished from endorphins, or endogenous opioid peptides. Exorphins include opioid food peptides like gluten exorphin and microbial opioid peptides and any other opioid peptide foreign to a host that have metabolic efficacy for that host. Exorphins can be converted from plants and animals but also dairy products and certain vegetables like spinach and soy. Exorphins can be released for many different kinds of proteins and thus can be isolated from various sources such as from plant proteins or from enzymes of the digestive system of animals. The study of exorphins as a bioactive peptide can be a source of discovery for new kinds of food and drugs to treat and prevent diseases associated with the accumulation of exorphins.
== History == Pacinian corpuscles were the first cellular sensory receptor ever observed. They were first reported by German anatomist and botanist Abraham Vater and his student Johannes Gottlieb Lehmann in 1741, but ultimately named after Italian anatomist Filippo Pacini, who rediscovered them in 1835. John Shekleton, a curator of the Royal College of Surgeons in Ireland, also discovered them before Pacini, but his results were published later. Similar to Pacinian corpuscles, Herbst corpuscles and Grandry corpuscles are found in bird species.
== External links == Anatomy figure: 20:06-01 at Human Anatomy Online, SUNY Downstate Medical Center - "The conduction system of the heart." Diagram at gru.net thoraxlesson4 at The Anatomy Lesson by Wesley Norman (Georgetown University) (thoraxheartinternalner) https://web.archive.org/web/20070929080346/http://www.healthyheart.nhs.uk/heart_works/heart03.shtml
Sources: en.wikipedia.org
In March 2018 Sara Rojas and her team published their research on drug incorporation and delivery with various biocompatible MOFs other than CD-MOF-1 through simulated cutaneous administration. The group studied the loading and release of ibuprofen (hydrophobic) and aspirin (hydrophilic) in three biocompatible MOFs (MIL-100(Fe), UiO-66(Zr), and MIL-127(Fe)). Under simulated cutaneous conditions (aqueous media at 37 °C) the six different combinations of drug-loaded MOFs fulfilled "the requirements to be used as topical drug delivery systems, such as released payload between 1 and 7 days" and delivering a therapeutic concentration of the drug of choice without causing unwanted side effects. The group discovered that the drug uptake is "governed by the hydrophilic/hydrophobic balance between cargo and matrix" and "the accessibility of the drug through the framework". The "controlled release under cutaneous conditions follows different kinetics profiles depending on: (i) the structure of the framework, with either a fast delivery from the open structure MIL-100 or a slower drug release from the narrow 1D pore system of MIL-127 or (ii) the hydrophobic/hydrophilic nature of the cargo, with a fast (Aspirin) and slow (Ibuprofen) release from the UiO-66 matrix." Moreover, a simple ball milling technique is used to efficiently encapsulate the model drugs 5-fluorouracil, caffeine, para-aminobenzoic acid, and benzocaine. Both computational and experimental studies confirm the suitability of [Zn4O(dmcapz)3] to incorporate high loadings of the studied bioactive molecules.
The building, at the cross sections of those streets that were once called Belascoaín, Carlos III, Fraternidad, and Pocito, is at 508 Avenida de Carlos III (English: Carlos III Avenue). To level the ground beneath the Temple, loads of soil and sand were brought in from each of the Six Provinces of Cuba and many of their major rivers; Camagüey Province, Havana Province, Las Villas Province, Matanzas Province, Oriente Province, and Pinar del Río Province.The building's cornerstone was laid on March 25, 1951, by Grand Master Carlos M. Piñero y del Cueto and the building's architect, Emilio Vasconcelos Frayde. Costs for the construction were made possible by voluntary donations donations from the Grand Lodge and Supreme Council of Cuba, and the Daughters of Acacia. A delegate from the Grand Lodge of Pennsylvania, upon seeing the Temple, wrote: "The cost of the temple was approximately US$4,000,000, and when we realize that there are but 31,700 Masons in Cuba, one can fully realize what a magnificent undertaking was brought to completion." On February 27, 1955, the National Masonic Temple of Cuba was officially inaugurated during the Third Inter-American Conference of Symbolic Freemasonry. At the consecration ceremony, Grand Master Carlos M. Piñeiro del Cueto said: "The consecration of the National Masonic Temple stands as a bulwark in the struggle for the freedom of all peoples and the dignity of mankind." At a height of eleven floors, it was at one time the second-tallest building on the entire island of Cuba.
====== Allergology ====== To train in the add-on specialty of allergology a physician must first be a specialist in general practice, occupational and environmental medicine, pediatric allergology, endocrinology and diabetology, geriatrics, hematology, dermatology and venerology, internal medicine, cardiology, clinical immunology and transfusion medicine, pulmonology, medical gastroenterology and hepatology, nephrology or otorhinolaryngology.
== Selective antagonists == All of the centrally active opioid antagonists used widely in medicine are non-selective, either blocking multiple opioid receptors, or blocking the MOR but activating the KOR. However, for scientific research, selective antagonists are needed which can block one of the opioid receptors but without affecting the others. This has led to the development of antagonists which are highly selective to one of the four receptors:
κ-Bungarotoxin (kappa-bungarotoxin) is a neurotoxin that is part of the bungarotoxin family. The neurotoxin can be found in the venom of the many-banded krait (Bungarus multicinctus). This snake species can be found in China, Myanmar, Laos, North Vietnam and Thailand. The toxin attacks the neuronal nicotinic acetylcholine receptors, inhibiting neurotransmission. Even though a snake bite of this species is rare, they do have a case-fatality range from 7% to 50%. Death can occur between 6 and 30 hours after a Bungarus multicinctus snakebite.
Sources: en.wikipedia.org
Primary drying removes ice by sublimation at low pressure and low shelf temperature. Secondary drying removes bound water by raising the shelf temperature, often under the same vacuum. The two stages differ in the water state being removed.
Freezing determines ice crystal size, pore structure, and the concentration of solutes in remaining liquid. Faster freezing generally creates smaller ice crystals and a denser dried matrix. These features affect drying rate and reconstitution behavior.
Lyophilization reduces water content but usually leaves a small amount of water in the dried material. Some water remains bound to solids or trapped in the dried matrix. Very low water targets can require extended secondary drying, which may alter product stability.
Freezing only converts liquid to solid. Lyophilization adds vacuum and controlled warming so frozen solvent sublimes, leaving a dry porous solid. The two steps are related but not interchangeable.