The short version of Karl Fischer titration fits in a sentence. The long version — which is the one that helps — is below.
This page was last updated on 2026-08-01 and is reviewed periodically as new material appears.
Lyophilization is a dehydration technique in which a product is frozen and the solvent is removed under reduced pressure. The low pressure allows ice to sublimate directly into vapor without passing through a bulk liquid phase. This differs from conventional drying, where heat drives evaporation and can damage heat-sensitive structures. The process is used for biological materials, pharmaceutical formulations, and some foods. Its main advantage is preservation of porous structure and rapid reconstitution.
Freezing is the first stage and sets the ice structure that later becomes the pore network. The formulation is cooled below its freezing point, often with a controlled ramp, and solutes concentrate as ice forms. Primary drying then lowers chamber pressure and supplies heat to sublime the ice. The product temperature must stay below its collapse or eutectic temperature to prevent structural loss. Secondary drying raises the temperature modestly to remove bound water and achieve a low residual moisture.
A freeze-dryer consists of a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. Vials, ampoules, or bulk trays hold the product during the cycle. The condenser traps water vapor as ice at a temperature lower than the product. Cycle development balances shelf temperature, chamber pressure, and time. Scale-up can be difficult because heat and mass transfer change with equipment size, so process analytical tools and conservative validation are often used.
Storage stability depends on water content, oxygen exposure, and temperature. Lyophilized solids are hygroscopic and can absorb water if exposed to humid air. Vials are usually sealed under vacuum or inert gas with rubber stoppers and aluminum crimps. Storage temperatures range from room temperature to refrigerated or frozen conditions depending on the material. Stability studies track potency, moisture, and physical form over time. Accelerated conditions can reveal sensitivity but may not predict long-term behavior.
Analytical methods for lyophilized materials include X-ray diffraction for crystallinity, differential scanning calorimetry for thermal transitions, and scanning electron microscopy for pore morphology. Moisture sorption analysis shows how the cake responds to humidity. These methods help distinguish amorphous from crystalline states and detect phase changes. Open questions remain about how pore structure changes during long-term storage and how best to predict collapse under varied conditions. Comparisons across studies are complicated by differences in formulation, cycle, and storage history.
Quality control for lyophilized products focuses on appearance, moisture level, reconstitution time, and structural integrity. A cake should be uniform, intact, and free of meltback or collapse. Moisture level is measured by Karl Fischer titration or thermogravimetric analysis. Reconstitution time reflects pore structure and formulation. Visual inspection and vial integrity checks detect cracks, stopper defects, or particulate matter. These checks are often performed on samples from each batch. They help confirm that the drying cycle performed as intended.
| Property | Value | Notes |
|---|---|---|
| Common synonyms | freeze-drying, lyophilisation, cryodesiccation | Lyophilization is common in pharmaceutical literature. |
| Typical chamber pressure during primary drying | 0.05–0.5 mbar (5–50 Pa) | Must remain below the triple point of water. |
| Typical shelf temperature during freezing | −40 to −20 °C | Lower temperatures may be used for eutectic systems. |
| Typical residual moisture after secondary drying | 0.5–3% w/w | Product-dependent; low moisture improves stability but can cause over-drying. |
| Typical analytical method for residual moisture | Karl Fischer titration or loss on drying | Thermogravimetric methods are also used. |
Equipment for lyophilization includes a vacuum chamber, temperature-controlled shelves, a condenser, and a vacuum pump. A refrigeration system cools the shelves and condenser below the product's freezing point. Process monitoring often uses Pirani and capacitance manometers, thermocouples, and resistance sensors. Cycle development balances product quality with time and energy use. Some products are annealed during freezing to improve crystallization of bulking agents. Open questions remain about scaling cycles between laboratory, pilot, and production freeze-dryers.
Lyophilization, also called freeze-drying, removes water from a frozen material by sublimation under reduced pressure. The process begins with freezing, which converts free water into ice and may also produce a glassy phase. Primary drying then lowers chamber pressure so ice sublimes directly to vapor without passing through a liquid stage. Secondary drying raises the temperature modestly to remove bound water. The result is a porous, dry solid that usually reconstitutes quickly. Each stage influences pore structure, residual moisture, and stability.
The physics of lyophilization depends on phase boundaries and heat and mass transfer. During primary drying, heat supplied to the product must equal the latent heat of sublimation, while water vapor moves through the drying cake to the condenser. If shelf temperature or pressure is set too high, the ice front can exceed the collapse temperature, causing meltback or pore collapse. If conditions are too cold, drying slows and costs rise. Formulation excipients, vial geometry, and freezing rate alter these limits.
Regulatory expectations for lyophilized products focus on consistent manufacture and documented stability. Batches are often monitored for moisture, appearance, potency, and sterility where applicable. Process parameters such as shelf temperature, chamber pressure, and drying time are recorded and controlled within validated ranges. Open questions remain about how best to predict long-term stability from short accelerated studies, especially for complex biologics. Variations in freezing rate and ice crystal size can produce differences that are not always visible but may affect performance.
After drying, a lyophilized product is usually sealed under vacuum or an inert gas to limit moisture uptake. Residual water content is measured because small changes can alter chemical stability and cake appearance. Storage temperature depends on the material; many biological products are kept at 2–8 °C, while some require −20 °C or colder. Exposure to ambient humidity during handling can cause the porous solid to absorb water and collapse. Container closures and stoppers are therefore selected for low moisture transmission and compatibility.
Scleroderma, polymyositis, and dermatomyositis elicit little or no CRP response. CRP levels also tend to remain low despite inflammatory activity in systemic lupus erythematosus (SLE) unless serositis or synovitis is present. This may be explained by increased levels of type I IFN in SLE, since type I IFN (i.e IFN alpha) inhibits hepatic CRP production. A polymorphisms of the CRP gene which cause lower CRP levels is also more frequent in SLE patients compared with controls. Elevations of CRP in the absence of clinically significant inflammation can occur in kidney failure. CRP level is an independent risk factor for atherosclerotic disease. Patients with high CRP concentrations are more likely to develop stroke, myocardial infarction, and severe peripheral vascular disease. Elevated level of CRP can also be observed in inflammatory bowel disease (IBD), including Crohn's disease and ulcerative colitis. High levels of CRP has been associated to point mutation Cys130Arg in the APOE gene, coding for apolipoprotein E, establishing a link between lipid values and inflammatory markers modulation.
=== Okinawa, Japan === Between 1995 and 1996, U.S. Marine AV-8B Harrier jets accidentally fired more than 1,500 DU rounds at the Tori Shima gunnery range. The military did not notify the Japanese government until January 1997.
== Protein kinase activation == The cGMP-dependent protein kinase (PKG) activation pathway begins with the production of cGMP by guanylyl cyclase enzymes, which can be activated by signaling molecules such as nitric oxide (NO) or natriuretic peptides. Elevated cGMP levels then lead to the activation of some protein-dependent kinases like PKG. For example, PKG (protein kinase G) is a dimer consisting of one catalytic and one regulatory unit, with the regulatory units blocking the active sites of the catalytic units. cGMP binds to sites on the regulatory units of PKG and activates the catalytic units, enabling them to phosphorylate their substrates. Unlike with the activation of some other protein kinases, notably PKA, the PKG is activated but the catalytic and regulatory units do not disassociate. Once activated, PKG phosphorylates various target proteins, altering their function and contributing to cellular processes such as smooth muscle relaxation, ion channel regulation, and inhibition of platelet aggregation. This pathway is also significant in cardiovascular physiology, where it helps maintain vascular tone and blood pressure.
John Russell (1893–1917), recipient of the Victoria Cross, born in Holyhead Ceinwen Rowlands (1905–1983), a Welsh concert soprano and recording artist, born in Holyhead R. S. Thomas (1913–2000), a Welsh poet and Anglican priest poet, grew up in Holyhead Cledwyn Hughes, Baron Cledwyn of Penrhos (1916–2001) MP & politician, born in Holyhead, attended Ysgol Uwchradd Caergybi Barbara Margaret Trimble (1921–1995) a British writer of over 20 crime, thriller and romance novels, born in Holyhead David Crystal (born 1941) linguist and chair of the charity behind Holyhead's Ucheldre Centre, lives in Holyhead Glenys Kinnock (1944-2023) a politician, MEP, educated at Holyhead High School Dawn French (born 1957 in Holyhead) comedian and actress, co-star in French and Saunders Albert Owen (born 1959 in Holyhead) politician, MP for Ynys Môn from 2001 to 2019. Kevin Johnson (born 1960 in Holyhead), a managing partner at Medicxi Ventures, a venture capital firm Jason Evans (born 1968 in Holyhead), a Welsh photographer and lecturer on photography Ben Crystal (born 1977), an English actor, author, and producer brought up in Holyhead Gareth Williams (1978–2010) worked for GCHQ and SIS died in suspicious circumstances
Sources: en.wikipedia.org
Western Region (Vancouver, Seattle, San Francisco Bay Area, Los Angeles) Central Region (Guadalajara, Mexico City, Monterrey, Houston, Dallas, Kansas City) Eastern Region (Atlanta, Miami, Toronto, Boston, Philadelphia, New York/New Jersey) However, even during the group stage, about half of the teams had to play matches in two different regions.
Physical organic chemistry, a term coined by Louis Hammett in 1940, refers to a discipline of organic chemistry that focuses on the relationship between chemical structures and reactivity, in particular, applying experimental tools of physical chemistry to the study of organic molecules. Specific focal points of study include the rates of organic reactions, the relative chemical stabilities of the starting materials, reactive intermediates, transition states, and products of chemical reactions, and non-covalent aspects of solvation and molecular interactions that influence chemical reactivity. Such studies provide theoretical and practical frameworks to understand how changes in structure in solution or solid-state contexts impact reaction mechanism and rate for each organic reaction of interest.
== History == MMDA was first synthesized and studied by Gordon Alles at the Edgewood Arsenal in the mid-1950s. Its Edgewood Arsenal code name is unknown. Subsequently, Alexander Shulgin synthesized MMDA in 1962 and discovered its psychoactive effects that same year. Shulgin published his findings on MMDA in the scientific literature in 1964. Use of MMDA in psychedelic-assisted psychotherapy was studied by Shulgin, Thornton Sargent, and Claudio Naranjo in the mid-1960s and their findings were published in 1973. Naranjo also described MMDA for these purposes in his 1973 book The Healing Journey: New Approaches to Consciousness. Shulgin subsequently further described MMDA in his book PiHKAL (Phenethylamines I Have Known and Loved) in 1991.
18 October – A study indicates there has been a substantial increase of sentiment negativity and decrease of emotional neutrality in headlines across written popular news media since 2000. 19 October – A novel type of effective hydrogen storage using readily available salts is reported. 20 October A study of PNMN, the world's largest no-fishing zone, finds a "spillover benefit" for migratory species like bigeye and yellowfin tuna. The first data transmission to exceed 1 petabit per second (Pbit/s) using only a single laser and a single optical chip is demonstrated by European researchers. 21 October – News outlets report about a novel agricultural robot for viable weed control using lasers or "laserweeding". There are similar precision agriculture machines that have been reported before, also e.g. applying low amounts of herbicides and fertilizers with precision while mapping plant locations, in some cases autonomously. Their benefits may include "healthier crops and soil, decreased herbicide use, and reduced chemical and labor costs". 24 October The NHS launches 'Our Future Health', one of the world's largest health and genetic data gathering projects, aimed at building a long-term repository of information for researchers. Five million UK adults are invited to participate. "Hybrid viral particles (HVPs)" are reported, combining IAV and RSV in vitro. 25 October – A comprehensive annually scheduled study finds climate change is "undermining every dimension of global health monitored" and reports dire conclusions from tracking of impact indicators.
== Historical aspects == Most natural polymers employed at early stages of human society are of condensation type. The synthesis of first truly synthetic polymeric material, bakelite, was announced by Leo Baekeland in 1907, through a typical step-growth polymerization fashion of phenol and formaldehyde. The pioneer of synthetic polymer science, Wallace Carothers, developed a new means of making polyesters through step-growth polymerization in 1930s as a research group leader at DuPont. It was the first reaction designed and carried out with the specific purpose of creating high-molecular-weight polymer molecules, as well as the first polymerization reaction whose results had been predicted by scientific theory. Carothers developed a series of mathematical equations to describe the behavior of step-growth polymerization systems which are still known as the Carothers equations today. Collaborating with Paul Flory, a physical chemist, they developed theories that describe more mathematical aspects of step-growth polymerization including kinetics, stoichiometry, molecular-weight distribution, etc. Carothers is also well-known for his invention of Nylon.
Sources: en.wikipedia.org
2024 United Kingdom riots: Two 12-year-old boys become the youngest people to be convicted following their involvement in the disorder. Figures show that 125 migrants crossed the English Channel in small boats. 13 August Banknotes featuring King Charles, with a face value of £78,430 and low serial numbers, are auctioned for £914,127 to raise money for charity. An inquest is held into the death of former England cricketer Graham Thorpe, who died from suicide after being struck by a train at a railway station. Data from the Office for National Statistics shows UK unemployment fell to 4.2% in the three months to June, down from 4.4% during the previous quarter. Ofgem approves a £3.4bn project for a subsea cable allowing renewable energy to be transported from Scotland to England more easily. 14 August Inflation is reported to have risen from 2% to 2.2%, the first increase during 2024. The predicted increase is largely a result of a smaller fall in gas and electricity prices in July when compared to July 2023. 2024 United Kingdom riots: A 53-year-old woman from Cheshire is sentenced to 15 months in prison after admitting sending a communication threatening death or serious harm over a Facebook post in which she suggested a mosque should "be blown up with the adults inside". Two men found in a burned-out car in Malmö, Sweden, are confirmed as two British men, Farooq Abdulrazak, 37, and Juan Cifuentes, 33, who went missing in July. Train drivers' union ASLEF is to ballot its members on a revised pay offer following negotiations with the Department for Transport.
Official U.S. Senate website Lathrop & Gage LLP – People – Eric S. Schmitt biography at his law firm Biography at the Biographical Directory of the United States Congress Financial information (federal office) at the Federal Election Commission Legislation sponsored at the Library of Congress Profile at Vote Smart "Voter Information for Eric Schmitt. November 4, 2008 Election". SmartVoter. League of Women Voters of California Education Fund. Retrieved April 6, 2009. Appearances on C-SPAN
== Further reading == John Bankston, Francis Crick and James D. Watson; Francis Crick and James Watson: Pioneers in DNA Research (Mitchell Lane Publishers, Inc., 2002) ISBN 1-58415-122-6. Bill Bryson; A Short History of Nearly Everything (Broadway Books, 2003) ISBN 0-7679-0817-1. Soraya De Chadarevian; Designs For Life: Molecular Biology After World War II, CUP 2002, 444 pp; ISBN 0-521-57078-6. Roderick Braithwaite. Strikingly Alive: The History of the Mill Hill School Foundation 1807–2007; published Phillimore & Co. ISBN 978-1-86077-330-3 Edwin Chargaff; Heraclitean Fire, Rockefeller Press, 1978. S. Chomet (Ed.), D.N.A. Genesis of a Discovery, 1994, Newman- Hemisphere Press, London Dickerson, Richard E.; Present at the Flood: How Structural Molecular Biology Came About, Sinauer, 2005; ISBN 0-87893-168-6. Edward Edelson, Francis Crick And James Watson: And the Building Blocks of Life, Oxford University Press, 2000, ISBN 0-19-513971-2. John Finch; A Nobel Fellow On Every Floor, Medical Research Council 2008, 381 pp, ISBN 978-1-84046-940-0. Hager, Thomas; Force of Nature: The Life of Linus Pauling, Simon & Schuster 1995; ISBN 0-684-80909-5 Graeme Hunter; Light Is A Messenger, the life and science of William Lawrence Bragg (Oxford University Press, 2004) ISBN 0-19-852921-X. Horace Freeland Judson, The Eighth Day of Creation. Makers of the Revolution in Biology; Penguin Books 1995, first published by Jonathan Cape, 1977; ISBN 0-14-017800-7. Errol C. Friedberg; Sydney Brenner: A Biography, pub. CSHL Press October 2010, ISBN 0-87969-947-7.
For example, Nature published a total of 1,782 articles in the 2015/2016 biennium (902 articles in 2015 and 880 in 2016); and 74,090 references listed by articles published (by any journal) in 2017 were sourced from within the group of 1,782 articles that Nature had published during the previous two years. These figures yielded an impact factor of
In 1916, Popielski described histamine as a gastric secretagogue of hydrochloric acid. William Beaumont was an army surgeon who in 1825, was able to observe digestion as it took place in the stomach. This was made possible by experiments on a man with a stomach wound that did not fully heal leaving an opening into the stomach. The churning motion of the stomach was described among other findings. In the 19th century, it was accepted that chemical processes were involved in the process of digestion. Physiological research into secretion and the gastrointestinal tract was pursued with experiments undertaken by Claude Bernard, Rudolph Heidenhain and Ivan Pavlov. The rest of the 20th century was dominated by research into enzymes. The first to be discovered was secretin by Ernest Starling in 1902, with ensuing results from John Edkins in 1905 who first suggested gastrin with its structure being determined in 1964. Andre Latarjet and Lester Dragstedt found a role for acetylcholine in the digestive system. In 1972, H2 receptor agonists were described by J. Black, that block the action of histamine and decrease the production of hydrochloric acid. In 1980, proton pump inhibitors were described by Sachs. In 1983, the role of Helicobacter pylori in the formation of ulcers was described by Barry Marshall, and Robin Warren. Art historians have often noted that banqueters on iconographic records of ancient Mediterranean societies almost always appear to be lying down on their left sides. One possible explanation could lie in the anatomy of the stomach and in the digestive mechanism.
Sources: en.wikipedia.org
Yes, the terms are generally interchangeable. Lyophilization is more common in pharmaceutical and laboratory contexts, while freeze-drying appears widely in food science and general writing. Both describe removal of solvent by sublimation under vacuum after freezing.
Reduced pressure keeps the process below the triple point of water, so ice can sublimate directly to vapor. It also lowers the temperature needed for drying, which helps preserve heat-sensitive materials. Without vacuum, melting or boiling could occur instead of controlled sublimation.
The rate depends on heat transfer to the product and mass transfer of vapor through the dried layer. A cold condenser, adequate vacuum, and suitable shelf temperature all influence speed. Formulation properties such as solid content and collapse temperature also set practical limits.
Karl Fischer titration is a common method, using coulometric or volumetric detection. Thermogravimetric analysis can also measure weight loss on heating. Results depend on sample handling because the dried solid can absorb moisture quickly.